Next Article in Journal
Optimizing Extraction Conditions of Free and Bound Phenolic Compounds from Rice By-Products and Their Antioxidant Effects
Next Article in Special Issue
Characterization of Aroma-Active Compounds in Seed Extract of Black Cumin (Nigella sativa L.) by Aroma Extract Dilution Analysis
Previous Article in Journal
Whole Grain Muffin Acceptance by Young Adults
 
 
Font Type:
Arial Georgia Verdana
Font Size:
Aa Aa Aa
Line Spacing:
Column Width:
Background:
Review

Potential Use of Bacillus coagulans in the Food Industry

Department of Food Engineering, Cukurova University, Adana 01330, Turkey
*
Author to whom correspondence should be addressed.
Foods 2018, 7(6), 92; https://doi.org/10.3390/foods7060092
Submission received: 1 May 2018 / Revised: 9 June 2018 / Accepted: 11 June 2018 / Published: 13 June 2018

Abstract

:
Probiotic microorganisms are generally considered to beneficially affect host health when used in adequate amounts. Although generally used in dairy products, they are also widely used in various commercial food products such as fermented meats, cereals, baby foods, fruit juices, and ice creams. Among lactic acid bacteria, Lactobacillus and Bifidobacterium are the most commonly used bacteria in probiotic foods, but they are not resistant to heat treatment. Probiotic food diversity is expected to be greater with the use of probiotics, which are resistant to heat treatment and gastrointestinal system conditions. Bacillus coagulans (B. coagulans) has recently attracted the attention of researchers and food manufacturers, as it exhibits characteristics of both the Bacillus and Lactobacillus genera. B. coagulans is a spore-forming bacterium which is resistant to high temperatures with its probiotic activity. In addition, a large number of studies have been carried out on the low-cost microbial production of industrially valuable products such as lactic acid and various enzymes of B. coagulans which have been used in food production. In this review, the importance of B. coagulans in food industry is discussed. Moreover, some studies on B. coagulans products and the use of B. coagulans as a probiotic in food products are summarized.

1. Introduction

Nowadays, the interest in probiotic foods is increasing due to the growing consumer demand for safe and functional foods with health-promoting properties and high nutritional value [1]. Probiotics are defined as “live microorganisms that, when administered in adequate amounts, confer a health benefit on the host” [2]. In order to obtain benefits, probiotic products should contain at least 107–109 cfu/g probiotic microorganism and should survive until the end of shelf life [3]. Probiotic microorganisms, which are naturally found in intestinal microbiota, could protect humans from diseases, modulate and strengthen the immune system, prevent tooth decay, have anticarcinogenic properties, and be effective against coronary heart disease [4,5]. Probiotic microorganisms can produce organic acids (such as lactic and acetic acid), hydrogen peroxide, and bacteriocin [5]. Probiotics have several mechanisms to inhibit pathogen microorganisms. The primary mechanisms are as follows: (1) the lowering of the pH of food through lactic acid production; (2) the production of antimicrobial substances such as microcin, hydrogen peroxide, and compounds like free radicals; (3) competition for food resources by attaching to receptors; and (4) stimulation of the production of secretory IgA (Immunoglobulin A) by the formation of protective mucin (parent substance of the mucus composed of tissue of epithelial or connective origin and a mixture of glycoprotein and mucoprotein) [5].
There are two basic forms of probiotic microorganisms used in foods: the vegetative form and the spore form. The vegetative form is more susceptible to high temperatures, moisture, acidity, shelf life of food, and negative environmental conditions during the manufacture of food than the spore form. However, some probiotic microorganisms do not have spore forms [4]. Fermentation conditions, freezing, thawing, drying, cell protection additives, rehydration of dried probiotics, and microencapsulation applications are factors that affect the survival of probiotic microorganisms during probiotic food production. Food compounds, food additives, oxygen content, redox potential, moisture content/water activity, storage temperature, pH and titration acidity, and packaging conditions are factors that also affect survival of probiotic microorganisms during storage [6]. Gastrointestinal system conditions and stress factors could cause significant loss of viable probiotic cells [7].
Lactic acid bacteria (LAB; for example, Lactobacillus and Bifidobacterium and some Saccharomyces species) are the microorganisms most commonly used in probiotic food production [8,9,10,11]. However, these microorganisms cannot survive heat treatment, for which the cold spot temperature is approximately 75 °C [8,10]. Heat treatment is not applicable for most probiotic foods that contain commercial probiotic microorganisms due to their sensitivity to heat. Nevertheless, it has been stated that this restriction could be overcome by the usage of spore-forming probiotic microorganisms. It is known that some non-pathogenic Bacillus species, which are not as well-known as LAB and yeasts, are being used as probiotics [12]. The survival and stability of these bacteria have considerably improved compared to others through their spore-forming abilities. They are identified as an ideal choice in order to development of functional foods by protecting their vitality in high-temperature applications [13,14].
Bacillus coagulans (B. coagulans) was firstly isolated from spoiled milk [6]. In 1933, it was identified as Lactobacillus sporogenes by Horowitz-Wlassowa and Nowotelnow. Afterwards, it was classified as B. coagulans [15].
B. coagulans is a gram-positive, facultative anaerobic, nonpathogenic, spore-forming, lactic acid-producing bacteria [4]. It is resistant to heat; the optimum growth temperature for B. coagulans is 35 to 50 °C and the optimum growth pH is 5.5 to 6.5 [4,15]. It has the characteristics of microorganisms used as probiotics [15]. Some strains of B. coagulans have been reported as facultative anaerobe, thermophile bacteria able to grow at pH 6.2, 60–65 °C [6,16]. Although B. coagulans produces acid, it does not produce gas from maltose, raffinose, mannitol, and sucrose fermentation. It was reported that B. coagulans causes deterioration in dairy, fruit, and vegetable products due to acid production. In addition to lactic acid production, some strains also produce thermostable α-amylase [4,17]. For this reason, B. coagulans is important from an industrial point of view. B. coagulans spores are terminal, while spores of other species are central or subterminal. Furthermore, it differs from other Bacillus species due to the absence of cytochrome-C oxidase, and it does not reduce nitrate to nitrite [4]. It was reported that B. coagulans could grow at pH 4.5 at 65 °C and was isolated from products containing milk and carbohydrate [18].
B. coagulans has been reported as safe by the US Food and Drug Administration (FDA) and the European Union Food Safety Authority (EFSA) and is on the Generally Recognized As Safe (GRAS) and Qualified Presumption of Safety (QPS) list [19]. In addition, it was reported that genome sequencing can provide information about the overall characterization of the bacterium, for example with respect to its safety as a food supplement [20]. The B. coagulans GBI-30, 6086 genome was investigated, and it was found that it did not contain any hazardous genes [21]. Some of the non-pathogenic strains among the 100 known Bacillus spp., including B. coagulans and Bacillus subtilis var. natto, were stated as safe for human consumption [22,23].

2. Probiotic Activity of B. coagulans

Heat-treated food products are generally not used for probiotic purposes because of the factors affecting their viability and stability [15]. In order to obviate this difficulty, B. coagulans, Bacillus racemilacticus, and Bacillus laevolacticus as well as the Sporolactobacillus genus could be used as probiotics due to their heat-resistant spore forms [12,15]. Although there are limited research studies on the use of Bacillus spp. in human nutrition, many food products containing B. coagulans have been sold in various countries (Table 1). Traditionally, probiotic microorganisms have been used as freeze-dried in probiotic food supplements, in dairy products such as yogurt, and in fermented beverages [24,25,26]. The viability and stability of these bacteria improved considerably compared to others by means of spore formation. It is stated that they are an ideal choice for the development of cereal-based functional products because they can maintain their viability in heat-treated processes such as baking and boiling. In addition, the spores gain a stable state during the food storage [13].
The survival rates of Lactobacillus strains are highly affected by the production process, storage, and transportation of food. It is reported that some strains of B. coagulans are better able to survive in high-temperature heat treatment and stomach conditions than other commercial probiotic microorganisms. It is suggested that strains which have these properties are likely to survive better in the digestive tract [29].
B. coagulans GBI-30, 6086 is a commercial probiotic mixture also known as GanedenBC30 [13,20]. Many research studies have been conducted and have reported the beneficial effects of B. coagulans GBI-30, 6086 on human and animal health [30,31,32]. It has been reported as safe by EFSA, and included in the GRAS and QPS list. It is available in various probiotic foods in markets [13,20].
In a study by Hyronimus et al. (2000) [12], the influence of pH value and bile salt concentration of culture media on LAB growth was observed. It was reported that B. coagulans was resistant to 0.3% bile salt concentration. In a study by Bora et al. (2009) [33], the effect of hygroscopicity, pH stability, and additives (lactose monohydrate, dibasic calcium phosphate dihydrate, microcrystalline cellulose, and corn starch) on B. coagulans spores were determined. The spores were found to be hygroscopic; maximum stability was screened at pH 6.8. There was no difference observed with additive addition.
In a study by Lee et al. (2017) [34], the probiotic activity of Bacillus spp. isolated from traditional Korean soy sauce was evaluated. Three of the isolates (MKSK-E1, MKSK-J1 and MKSK-M1) were found to be quite resistant to gastrointestinal tract conditions and showed antibacterial activity against B. cereus, Listeria monocytogenes (L. monocytogenes), Staphylococcus aureus (S. aureus), and Escherichia coli (E. coli). It was stated that these isolates could be used as probiotics in functional foods and animal feeds by evaluating antibiotic resistance, biogenic amine production, and hemolytic properties.
In a number of studies, antimicrobial activity of bacteriocin produced from B. coagulans was evaluated. Abada (2008) [35], reported that bacteriocin produced from B. coagulans had an inhibitory effect against E. coli (NCTC-10418), Pseudomonas aeruginosa (NCIB-9016), Klebsiella pneumoniae (NCIB-9111), B. subtilis (NCTC-6346), Staphylococcus aureus (S. aureus) (NCTC7447), and Candida albicans (CBS-562). Natarajaseenivasan et al. (2015) [36] reported on the antimicrobial effect of bacteriocin produced from Bacillus coagulans BDU3, which was isolated from traditional fermented fish. It was stated that it has an inhibitory effect on food-borne pathogens such as B. cereus MTCC 430, S. aureus MTCC 3160, Enterococcus sp. MTCC 9728, Lactobacillus sp. MTCC 10093, and Micrococcus luteus MTCC 106. In addition, it was found that Bacillus coagulans BDU3 survived in pH 2.0 and 0.2% bile salt concentration. Senna and Lathrop (2017) [37] reported that B. coagulans had an antifungal effect on Botrytis cinereal, Fusarium pallidoroseum, and Fusarium moniliforme. Donskey et al. (2001) [38], researched the antimicrobial effect of B. coagulans on vancomycin-resistant enterococcus found in rat intestine. Rats were fed with B. coagulans at a concentration of 107 cfu/g for 4 days. B. coagulans showed an inhibitory effect on vancomycin-resistant enterococci count.
According to the Jafari et al. (2016) [39], viability and growth of B. coagulans spores in sausages were affected by formulation, chopping, and surfactant. In a study by Jafari et al. (2017) [40], B. subtilis var. natto ATCC 15245 and Bacillus coagulans ATCC 31284 spores were inoculated in sausages. Different household-type cooking methods (boiling, microwave cooking, and deep frying) and cold storage were applied to sausages and survival rate of spores were evaluated. They reported that after heat treatment, the B. coagulans count was sufficient to define the sausages as probiotic. In another study by Taguchi (1986) [41], it is reported that spore count was affected by sausage formulation and cooking method. Fares et al. (2015) [13] used B. coagulans GBI-30, 6086 in order to produce functional pasta. After the production processes and cooking (5–7 min) were applied, the B. coagulans count was 9 log cfu/100g. They reported that this concentration of probiotic bacteria containing in pasta was enough to show a beneficial effect for consumers, with high nutritional value and sensorial properties.
Generally, probiotic Bacillus-containing foods and feeds are used as food supplements for humans, growth enhancers for animals, and growth regulators or protectors against diseases in aquaculture [26]. It is reported that regular consumption of probiotic microorganism-containing products strengthens the immune system, exhibits an anti-allergy effect, reduces cancer risk, lowers cholesterol, prevents digestive problems, and reduces gastrointestinal system infections [3]. It is reported that if B. clausii, B. coagulans, and B. subtilis-containing probiotic preparations are consumed on a regular basis, gastrointestinal disorders such as childhood diarrhea can be prevented [42,43,44] and the duration of respiratory tract infections in children is reduced [45]. These preparations can also be used in the treatment of symptoms associated with irritable bowel syndrome [46]. Endres et al. (2009) [29] performed a bacterial reverse mutation test, chromosomal abnormality test, micronucleus test, acute and 90-day sub-chronic recurrent toxicity test, and an acute eye and skin irritation test in order to determine toxicological properties of B. coagulans. It was reported that B. coagulans was found suitable for human consumption.
In the case of B. coagulans consumed as a feed additive, it prevents E. coli and Staphylococcus infections in gastrointestinal system and significantly improves the development of animals (such as poultry, pigs, etc.) by increasing digestibility [4].

3. Products of B. coagulans

In recent years, biological production of many metabolites (such as ethanol, lactic acid, fumaric acid, xylonix acid and other important products) has attracted greater attention as compared to chemical production with petroleum materials [47]. Various substances produced by B. coagulans are shown in Table 2.
Among these metabolites, lactic acid is an important product based on its high yield. Due to the demand for biodegradable and biocompatible materials, interest in lactic acid is increasing day by day [47]. B. coagulans is an ideal microorganism in industrial lactic acid production due to its ability to ferment glucose and xylose to lactic acid in anaerobic conditions at temperatures under 50 °C [68,69,70]. In many research studies, lactic acid production from B. coagulans was carried out using sugarcane pulp [49], sorghum water [50,51], coffee extract [52], wheat straw [53], corn cob [54,55], lignocellulosic hydrolysate [71], and corn flour [56] as substrates.
β-galactosidase is used for lactose hydrolysis in the food industry. It is found commonly in nature, and isolated from animals, plants, and microorganisms. It is a widely used enzyme in the food and pharmaceutical industry. Production of this enzyme from microorganisms allows for higher yields and a greater technological advantage compared to other sources. β-galactosidase also could be produced by several yeast (Kluyveromyces lactis and Kluyveromyces marxianus), mold (Aspergillus niger and Aspergillus oryzae), and bacteria (B. circulans, E. coli, Lactobacillus bulgaricus, Lactobacillus thermophile, Geobacillus stearothermophilus), with the exception of B. coagulans [72,73]. α-galactosidase is an important enzyme in the food industry, and is used many applications, especially in sugar production, biotechnology, and medicine. The most important use in the food industry is sugar production. α-galactosidase can also facilitate the digestion of legumes, such as soybean, through removing galactosides such as raffinose and stachyose from their structures and enhancing the gelation capacities of galactomannans [74]. Several studies have reported on α-galactosidase produced by B. coagulans [62,63].
It has been reported that B. coagulans has proteolytic activity [75,76]. Amylases are important hydrolase enzymes that have been used for many years. α-amylases are demanded in high amounts due to their wide industrial applications. α-amylases can be produced from plants and microorganisms. Being a cheap source of α-amylase production, microbial production is attracting attention as compared to others [77,78]. In many studies, α-amylase production was carried out using B. coagulans [64,78]. There is a great interest in the production of lipases from microorganisms, despite the presence of lipase in many animals, plants, and microorganisms. It is widely used in the food industry as well as in the pharmaceutical, textile, and cosmetic industry [79,80]. Among bacteria, a few Bacillus species are identified as producing lipase [81]. In previous studies, lipase production from B. coagulans was determined [65,66,67,81].
Xylanase is widely used in clarification process of fruit juices and wines. Several studies have been carried out to produce xylanase by B. coagulans [82,83].

4. Conclusions

Consumer interest in healthier and more functional food is increasing due to changing consumption habits and increasing interest in food and health. In addition to supporting the clinically beneficial effects of probiotic microorganisms on health, the formulation of probiotic food products has great importance for consumers, industry, and research centers which are interested in the subject. Heat-resistance of probiotic Bacillus spp. spore forms can provide an advantage for heat-treated probiotic foods. B. coagulans is attracting interest due to its resistance to strong gastric acid and high temperatures, and it is more resistant to antibiotics than other LAB. Moreover, the products, which are used in food industry and could be produced by B. coagulans, are gaining attention due to their low cost and as an alternative to other chemical sources.

Author Contributions

G.K. and Z.E. equally contributed to the background research, writing, and reviewing of this manuscript.

Funding

This research received no external funding.

Conflicts of Interest

The authors declare no conflict of interest.

References

  1. Kesenkaş, H.; Kınık, Ö.; Seçkin, K.; Günç Ergönül, P.; Akan, E. Keçi sütünden üretilen sinbiyotik beyaz peynirde Enterococcus faecium, Bifidobacterium longum ve Lactobacillus paracasei ssp. paracasei sayılarının değişimi. Ege Üniv. Ziraat Fak. Derg. 2018, 53, 75–81. [Google Scholar]
  2. Lebeer, S.; Bron, P.A.; Marco, M.L.; Pijkeren, J.P.V.; Motherway, M.O.; Hill, C.; Pot, B.; Roos, S.; Klaenhammer, T. Identification of probiotic effector molecules: Present state and future perspectives. Curr. Opin. Biotechnol. 2018, 49, 217–223. [Google Scholar] [CrossRef] [PubMed]
  3. Küçükçetin, A.; Göçer, E.M.Ç.; Ergin, F.; Arslan, A.A. Farklı inkübasyon sıcaklığı ile inkübasyon sonlandırma pH’sının probiyotik yoğurdun fizikokimyasal ve mikrobiyolojik özellikleri üzerine etkisi. Akademik Gıda 2016, 14, 341–350. [Google Scholar]
  4. Aşan Özüsağlam, M. Importance of Bacillus coagulans Bacterium as Probiotic in Animal Nutrition. Süleyman Demirel Üniv. Ziraat Fak. Derg. 2010, 5, 50–57. [Google Scholar]
  5. Kalkan, S. Probiyotik laktik asit bakterilerinin Staphylococcus aureus’a karşı antimikrobiyel etkilerinin farklı matematiksel modeller ile analizi. Sinop Univ. J. Nat. Sci. 2016, 1, 150–159. [Google Scholar]
  6. Kristjansson, J.K. Thermophilic Bacteria; CRC Press: Boca Raton, FL, USA, 1991; pp. 26–29. [Google Scholar]
  7. Ünal Turhan, E.; Erginkaya, Z.; Polat, S.; Özer, E.A. Design of probiotic dry fermented sausage (sucuk) production with microencapsulated and free cells of Lactobacillus rhamnosus. Turk. J. Vet. Anim. Sci. 2017, 41, 598–603. [Google Scholar] [CrossRef]
  8. Ruiz, L.; Ruas-Madiedo, P.; Gueimonde, M.; De Los Reyes-Gavilán, C.G.; Margolles, A.; Sánchez, B. How do Bifidobacteria counteract environmental challenges? Mechanisms involved and physiological consequences. Genes Nutr. 2011, 6, 307–318. [Google Scholar] [CrossRef] [PubMed]
  9. Budak Bağdatlı, A.; Kundakçı, A. Fermente et ürünlerinde probiyotik mikroorganizmaların kullanımı. Celal Bayar Üniv. J. Sci. 2013, 9, 31–37. [Google Scholar]
  10. Baka, M.; Noriega, E.; Tsakali, E.; Van, I.; Van Impe, J.F.M. Influence of composition and processing of Frankfurter sausages on the growth dynamics of Listeria monocytogenes under vacuum. Food Res. Int. 2015, 70, 94–100. [Google Scholar] [CrossRef]
  11. Garriga, M.; Aymerich, T.; Jofré, A. Probiotic fermented sausages: Myth or reality? Procedia Food Sci. 2015, 5, 133–136. [Google Scholar]
  12. Hyronimus, B.; Le Marrec, C.; Sassi, A.H.; Deschamps, A. Acid and bile tolerance of spore-forming lactic acid bacteria. Int. J. Food Microbiol. 2000, 61, 193–197. [Google Scholar] [CrossRef]
  13. Fares, C.; Menga, V.; Martina, A.; Pellegrini, N. Nutritional profile and cooking quality of a new functional pasta naturally enriched in phenolic acids, added with β-glucan and Bacillus coagulans GBI-30, 6086. J. Cereal Sci. 2015, 65, 260–266. [Google Scholar] [CrossRef]
  14. Hosseini, H.; Pilevar, Z. Effects of starter cultures on the properties of meat products: A review. Ann. Res. Rev. Biol. 2017, 17, 1–17. [Google Scholar]
  15. Karri, S.K.; Majeed, M.; Natarajan, S.; Sivakumar, A.; Ali, F.; Pande, A.; Majeed, S. Evaluation of anti-diarrhoeal activity of Bacillus coagulans MTCC 5856 and its effect on gastrointestinal motilıty in wistar rats. Int. J. Pharm. Biol. Sci. 2016, 7, 311–316. [Google Scholar]
  16. Benson, K.F.; Redman, K.A.; Carter, S.G.; Keller, D.; Farmer, S.; Endres, J.R.; Jensen, S.J. Probiotic metabolites from Bacillus coagulans GanedenBC30TM support maturation of antigen-presenting cells in vitro. World J. Gastroenterol. 2012, 18, 1875–1883. [Google Scholar] [CrossRef] [PubMed]
  17. De Clerk, E.; Rodriguez-Diaz, M.; Forsyth, G.; Lebbe, L.; Logan, N.A.; DeVos, P. Polyphasic characterization of Bacillus coagulans strains, illustrating heterogeneity within this species, and emended description of the species. Syst. Appl. Microbiol. 2004, 27, 50–60. [Google Scholar] [CrossRef] [PubMed]
  18. Ercan Akkaya, S.; Kıvanç, M. Termofil bakteriler; sıcak su kaynaklarında yaşayan Gr (+) basillerin izolasyon ve identifikasyon yöntemleri. AKÜ Fen Bilim. Derg. 2008, 2, 61–70. [Google Scholar]
  19. EFSA. Scientific Opinion on The Maintenance of the List of QPS Biological Agents Intentionally Added to Food and Feed (2013 update). EFSA J. 2013, 11, 3449. [Google Scholar] [CrossRef] [Green Version]
  20. Orrù, L.; Salvetti, E.; Cattivelli, L.; Lamontanara, A.; Michelotti, V.; Capozzi, V.; Spano, G.; Keller, D.; Cash, H.; Martina, A.; et al. Draft genome sequence of Bacillus coagulans GBI-30, 6086, a widely used spore-forming probiotic strain. Genome Announc. 2014, 2. [Google Scholar] [CrossRef] [PubMed]
  21. Salvetti, E.; Orrù, L.; Capozzi, V.; Martina, A.; Lamontanara, A.; Keller, D.; Cash, H.; Felis, G.E.; Cattivelli, L.; Torriani, S.; et al. Integrate genome-based assessment of safety for probiotic strains: Bacillus coagulans GBI-30, 6086 as a case study. Appl. Microbiol. Biotechnol. 2016, 100, 4595–4605. [Google Scholar] [CrossRef] [PubMed]
  22. Urdaci, M.C.; Bressollier, P.; Pinchuk, I. Bacillus clausii probiotic strains: Antimicrobial and immunomodulatory activities. J. Clin. Gastroenterol. 2004, 38, 86–90. [Google Scholar] [CrossRef]
  23. Nithya, V.; Halami, P. Evaluation of the probiotic characteristics of Bacillus species isolated from different food sources. Ann. Microbiol. 2013, 63, 129–137. [Google Scholar] [CrossRef]
  24. Gülmez, M.; Güven, A. Probiyotik, prebiyotik ve sinbiyotikler. Kafkas Üniv. Vet. Fak. Derg. 2002, 8, 83–89. [Google Scholar]
  25. Uymaz, B. Probiyotikler ve kullanım alanları. Pamukkale Üniv. Müh. Bilim. Derg. 2010, 16, 95–104. [Google Scholar]
  26. Cutting, S.M. Bacillus probiotics. Food Microbiol. 2011, 28, 214–220. [Google Scholar] [CrossRef] [PubMed]
  27. Elshaghabee, F.M.F.; Rokana, N.; Gulhane, R.D.; Sharma, C.; Panwar, H. Bacillus as Potential Probiotics: Status, Concerns, and Future Perspectives. Frontiers Microbiol. 2017, 8, 1490. [Google Scholar] [CrossRef] [PubMed]
  28. Kalman, D.S.; Schwartz, H.I.; Alvarez, P.; Feldman, S.; Pezzullo, J.C.; Krieger, D.R. A prospective, randomized, double-blind, placebo-controlled parallel-group dual site trial to evaluate the effects of a Bacillus coagulans-based product on functional intestinal gas symptoms. BMC Gastroenterol. 2009, 9, 85. [Google Scholar] [CrossRef] [PubMed]
  29. Endres, J.R.; Clewell, A.; Jade, K.A.; Farber, T.; Hauswirth, J.; Schauss, A.G. Safety assessment of a proprietary preparation of a novel probiotic, Bacillus coagulans, as a food ingredient. Food Chem. Toxicol. 2009, 47, 1231–1238. [Google Scholar] [CrossRef] [PubMed]
  30. Siezen, R.J.; Wilson, G. Probiotics genomics. Microb. Biotechnol. 2010, 3, 1–9. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  31. Honda, H.; Hoyles, L.; Gibson, G.; Farmer, S.; Keller, D.; McCartney, A.L. Impact of GanedenBC30 (Bacillus coagulans GBI-30, 6086) on population dynamics of the human gut microbiota in a continuous culture fermentation system. Int. J. Probiot. Prebiot. 2011, 6, 65–72. [Google Scholar]
  32. Jäger, R.; Shields, K.A.; Lowery, R.P.; De Souza, E.O.; Partl, J.M.; Hollmer, C.; Purpura, M.; Wilson, J.M. Probiotic Bacillus coagulans GBI-30, 6086 reduces exercise-induced muscle damage and increases recovery. PeerJ 2016, 4, e2276. [Google Scholar] [CrossRef] [PubMed]
  33. Bora, P.S.; Puri, V.; Bansal, A.K. Physicochemical Properties and Excipient Compatibility studies of Probiotic Bacillus coagulans Spores. Sci. Pharm. 2009, 77, 625–637. [Google Scholar] [CrossRef]
  34. Lee, S.; Lee, J.; Jin, Y.I.; Jeong, J.C.; Chang, Y.K.; Lee, Y.; Jeong, Y.; Kim, M. Probiotic characteristics of Bacillus strains isolated from Korean traditional soy sauce. LWT—Food Sci. Technol. 2017, 79, 518–524. [Google Scholar] [CrossRef]
  35. Abada, E.A.E. Isolation and characterization of an antimicrobial compound from Bacillus coagulans. Anima. Cells Syst. 2008, 12, 41–46. [Google Scholar] [CrossRef]
  36. Natarajaseenivasan, K.; Abdhul, K.; Ganesh, M.; Shanmughapriya, S.; Vanithamani, S.; Kanagavel, M.; Anbarasu, K. Bacteriocinogenic potential of a probiotic strain Bacillus coagulans [BDU3] from Ngari. Int. J. Biol. Macromol. 2015, 79, 800–806. [Google Scholar]
  37. Senna, A.; Lathrop, A. Antifungal Screening of Bioprotective Isolates against Botrytis cinerea, Fusarium pallidoroseum and Fusarium moniliforme. Fermentation 2017, 3, 53. [Google Scholar] [CrossRef]
  38. Donskey, C.J.; Hoyen, C.K.; Das, S.M.; Farmer, S.; Dery, M.; Bonomo, R.A. Effect of Oral Bacillus coagulans Administration on the Density of Vancomycin-Resistant Enterococci in the Stool of Colonized Mice. Lett. Appl. Microbiol. 2001, 33, 84–88. [Google Scholar] [CrossRef] [PubMed]
  39. Jafari, M.; Mortazavian, A.M.; Alebouyeh, M.; Hosseini, H.; Ghanati, K.; Zali, M.R. Recovery of Bacillus coagulans as a probiotic spore former in the raw batter of cocktail sausage as influenced by chopping, formulation and surfactant. Int. J. Life Sci. Pharm. Res. 2016, 2, 39–48. [Google Scholar]
  40. Jafari, M.; Mortazavian, A.M.; Hosseini, H.; Safaei, F.; Khaneghah, A.M.; Sant’Ana, A.S. Probiotic Bacillus: Fate during sausage processing and storage andinfluence of different culturing conditions on recovery of their spores. Food Res. Int. 2017, 95, 46–51. [Google Scholar] [CrossRef] [PubMed]
  41. Taguchi, G. Introduction to quality engineering: Designing quality into products and processes. Tokyo Asian Prod. Org. 1986, 191. [Google Scholar]
  42. Hong, H.A.; Duc, L.H.; Cutting, S.M. The use of bacterial spore formers as probiotics. FEMS Microbiol. Rev. 2005, 29, 813–835. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  43. Jurenka, J.S. Bacillus coagulans. Altern. Med. Rev. 2012, 17, 76–81. [Google Scholar] [PubMed]
  44. Fijan, S. Microorganisms with Claimed Probiotic Properties: An Overview of Recent Literature. Int. J. Environ. Res. Public Health 2014, 11, 4745–4767. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  45. Marseglia, G.L.; Tosca, M.; Cirillo, I.; Licari, A.; Leone, M.; Marseglia, A.; Castellazzi, A.M.; Ciprandi, G. Efficacy of Bacillus clausii spores in the prevention of recurrent respiratory infections in children: A pilot study. Ther. Clin. Risk Manag. 2007, 3, 13–17. [Google Scholar] [CrossRef] [PubMed]
  46. Tompkins, T.A.; Xu, X.; Ahmarani, J. A comprehensive review of post-market clinical studies performed in adults with an Asian probiotic formulation. Benef. Microbes 2010, 1, 93–106. [Google Scholar] [CrossRef] [PubMed]
  47. Zhou, J.; Ouyang, J.; Xu, Q.; Zheng, Z. Cost-effective simultaneous saccharification and fermentation of L-lactic acid from bagasse sulfite pulp by Bacillus coagulans CC17. Bioresour. Technol. 2016, 222, 431–438. [Google Scholar] [CrossRef] [PubMed]
  48. Maas, R.H.W.; Bakker, R.R.; Jansen, M.L.A.; Visser, D.; de Jong, E.; Eggink, G.; Weusthuis, R.A. Lactic acid production from lime-treated wheat straw by Bacillus coagulans: Neutralization of acid by fed-batch addition of alkaline substrate. Appl. Microbiol. Biotechnol. 2008, 78, 751–758. [Google Scholar] [CrossRef] [PubMed]
  49. Van der Pol, E.C.; Eggink, G.; Weusthuis, R.A. Production of l-(+)-lactic acid from acid pretreated sugarcane bagasse using Bacillus coagulans DSM2314 in a simultaneous saccharification and fermentation strategy. Biotechnol. Biofuels 2016, 9, 248. [Google Scholar] [CrossRef] [PubMed]
  50. Ou, M.S.; Awasthi, D.; Nieves, I.; Wang, L.; Erickson, J.; Vermerris, W.; Ingram, L.O.; Shanmugam, K.T. Sweet sorghum juice and bagasse as feedstocks for the production of optically pure lactic acid by native and engineered bacillus coagulans strains. Bioenergy. Res. 2016, 9, 123–131. [Google Scholar] [CrossRef]
  51. Wang, Y.; Chen, C.; Cai, D.; Wang, Z.; Qin, P.; Tan, T. The optimization of L-lactic acid production from sweet sorghum juice by mixed fermentation of Bacillus coagulans and Lactobacillus rhamnosus under unsterile conditions. Bioresour. Technol. 2016, 218, 1098–1105. [Google Scholar] [CrossRef] [PubMed]
  52. Neu, A.K.; Pleissner, D.; Mehlmann, K.; Schneider, R.; Puerta-Quintero, G.I.; Venus, J. Fermentative utilization of coffee mucilage using Bacillus coagulans and investigation of down-stream processing of fermentation broth for optically pure l-(+)-lactic acid production. Bioresour. Technol. 2016, 211, 398–405. [Google Scholar] [CrossRef] [PubMed]
  53. Zhang, Y.; Chen, X.; Luo, J.; Qi, B.; Wan, Y. An efficient process for lactic acid production from wheat straw by a newly isolated Bacillus coagulans strain IPE22. Bioresour. Technol. 2014, 158, 396–399. [Google Scholar] [CrossRef] [PubMed]
  54. Hu, J.; Zhang, Z.; Lin, Y.; Zhao, S.; Mei, Y.; Liang, Y.; Peng, N. High-titer lactic acid production from NaOH-pretreated corn stover by Bacillus coagulans LA204 using fed-batch simultaneous saccharification and fermentation under non-sterile condition. Bioresour. Technol. 2015, 182, 251–257. [Google Scholar] [CrossRef] [PubMed]
  55. Ma, K.; Hu, G.; Pan, L.; Wang, Z.; Zhou, Y.; Wang, Y.; Ruan, Z.; He, M. Highly efficient production of optically pure L-lactic acid from corn stover hydrolysate by thermophilic Bacillus coagulans. Bioresour. Technol. 2016, 219, 114–122. [Google Scholar] [CrossRef] [PubMed]
  56. Lv, X.; Yu, B.; Tian, X.; Chen, Y.; Wang, Z.; Zhuang, Y.; Wang, Y. Effect of pH, glucoamylase, pullulanase and invertase addition on the degradation of residual sugar in l-lactic acid fermentation by Bacillus coagulans HL-5 with corn flour hydrolysate. J. Taiwan Inst. Chem. Eng. 2016, 61, 124–131. [Google Scholar] [CrossRef]
  57. Payot, T.; Chemaly, Z.; Fick, M. Lactic acid production by Bacillus coagulans—Kinetic studies and optimization of culture medium for batch and continuous fermentations. Enzyme Microbial Technol. 1999, 24, 191–199. [Google Scholar] [CrossRef]
  58. Fan, R.; Ebrahimi, M.; Quitmann, H.; Aden, M.; Czermak, P. An Innovative Optical Sensor for the Online Monitoring and Control of Biomass Concentration in a Membrane Bioreactor System for Lactic Acid Production. Sensors 2016, 16, 411. [Google Scholar] [CrossRef] [PubMed] [Green Version]
  59. Coelho, L.F.; Beitel, S.M.; Sass, D.C.; Neto, P.M.A.; Contiero, J. High-titer and productivity of l-(+)-lactic acid using exponential fed-batch fermentation with Bacillus coagulans arr4, a new thermotolerant bacterial strain. 3 Biotech 2018, 8, 213. [Google Scholar] [CrossRef] [PubMed]
  60. Juturu, V.; Wu, J.C. Production of high concentration of l-lactic acid from oil palm empty fruit bunch by thermophilic Bacillus coagulans JI12. Biotechn. App. Biochem. 2018, 65, 145–149. [Google Scholar] [CrossRef] [PubMed]
  61. Batra, N.; Singh, J.; Banerjee, U.C.; Patnaik, P.R.; Sobti, R.C. Production and characterization of a thermostable β-galactosidase from Bacillus coagulans RCS3. Biotechnol. Appl. Biochem. 2002, 36, 1–6. [Google Scholar] [CrossRef] [PubMed]
  62. Nam, K.H.; Jang, M.S.; Park, H.Y.; Koneva, E. Biochemical characterization of α-galactosidase-producing thermophilic Bacillus coagulans KM-1. Korean J. Fish. Aquat. Sci. 2014, 47, 516–521. [Google Scholar] [CrossRef]
  63. Parkouda, C.; Diawara, B.; Debrah, K. Enzyme profiles of potential starter cultures for the fermentation of baobab seeds. Afr. J. Food Sci. 2014, 8, 249–252. [Google Scholar]
  64. Babu, K.R.; Satyanarayana, T. α-amylase production by thermophilic Bacillus coagulans in solid state fermentation. Process Biochem. 1995, 30, 305–309. [Google Scholar] [CrossRef]
  65. Lianghua, T.; Liming, X. Purification and partial characterization of a lipase from Bacillus coagulans ZJU318. Appl. Biochem. Biotechnol. 2005, 125, 139–146. [Google Scholar] [CrossRef]
  66. Alkan, H.; Baysal, Z.; Uyar, F.; Doğru, M. Production of lipase by a newly isolated Bacillus coagulans under solid-state fermentation using melon wastes. Appl. Biochem. Biotechnol. 2007, 136, 183–192. [Google Scholar] [CrossRef] [PubMed]
  67. Gowthami, P.; Muthukumar, K.; Velan, M. Utilization of coconut oil cake for the production of lipase using Bacillus coagulans VKl1. Biocontrol Sci. 2015, 20, 125–133. [Google Scholar] [CrossRef] [PubMed]
  68. Jiang, T.; Qiao, H.; Zheng, Z.; Chu, Q.; Li, X.; Yong, Q.; Ouyang, J. Lactic acid production from pretreated hydrolysates of corn stover by a newly developed Bacillus coagulans strain. PLoS ONE 2016, 11, e0149101. [Google Scholar] [CrossRef] [PubMed]
  69. Juturu, V.; Wu, J.C. Microbial production of lactic acid: The latest development. Crit. Rev. Biotechol. 2016, 36, 967–977. [Google Scholar] [CrossRef] [PubMed]
  70. Glaser, R.; Venus, J. Co-fermentation of the main sugar types from a beechwood organosolv hydrolysate by several strains of Bacillus coagulans results in effective lactic acid production. Biotechnol. Rep. 2018, 18, e00245. [Google Scholar] [CrossRef] [PubMed]
  71. Aulitto, M.; Fusco, S.; Bartolucci, S.; Franzen, C.J.; Contursi, P. Bacillus coagulans MA-13: A promising thermophilic and cellulolytic strain for the production of lactic acid from lignocellulosic hydrolysate. Biotechnol. Biofuels 2017, 10, 210. [Google Scholar] [CrossRef] [PubMed]
  72. Sharma, A.; Devl, K. Isolation and characterization of Escherichia coli producing β galactosidase from raw milk of dairy industry. Int. J. Adv. Sci. Technol. Res. 2016, 6, 163–179. [Google Scholar]
  73. Jensen, T.Ø.; Pogrebnyakov, I.; Falkenberg, K.B.; Redl, S.; Nielsen, A.T. Application of the thermostable β-galactosidase, BgaB, from Geobacillus stearothermophilus as a versatile reporter under anaerobic and aerobic conditions. AMB Express 2017, 7, 169. [Google Scholar] [CrossRef] [PubMed]
  74. Gürkök, S.; Söyler, B.; Ögel, Z.B. Aspergillus fumigatus alfa-galaktosidaz enziminin Aspergillus sojae’de heterolog ifadesi ve osmotik stresin etkisi. In Proceedings of the Türkiye 10. Gıda Kongresi, Erzurum, Turkey, 21–23 May 2008. [Google Scholar]
  75. Prihanto, A.A.; Darius; Firdaus, M. Proteolytic and fibrinolytic activities of halophilic lactic acid bacteria from two Indonesian fermented foods. J. Microbiol. Biotechnol. Food Sci. 2013, 2, 2291–2293. [Google Scholar]
  76. Reyes-Mendez, A.I.; Figueroa-Hernandez, C.; Melgar-Lalanne, G.; Hernandez-Sanchez, H.; Davila-Ortiz, G.; Jimenez-Martinez, C. Production of calcium- and iron-binding peptides by probiotic strains of Bacillus subtilis, B. clausii and B. coagulans GBI-30. Rev. Mex. Ing. Quimica 2015, 14, 1–9. [Google Scholar]
  77. Sundarram, A.; Murthy, T.P.K. α-amylase production and applications: A review. J. Appl. Env. Microbiol. 2014, 2, 166–175. [Google Scholar]
  78. Keating, L.; Kelly, C.; Fogarty, W. Mechanism of action and the substrate dependent pH maximum shift of the α-amylase of Bacillus coagulans. Carbohydr. Res. 1998, 309, 311–318. [Google Scholar] [CrossRef]
  79. Kumar, S.; Kikon, K.; Upadhyay, A.; Kanwar, S.S.; Gupta, R. Production, purification, and characterization of lipase from thermophilic and alkaliphilic Bacillus coagulans BTS-3. Protein Expr. Purif. 2005, 41, 38–44. [Google Scholar] [CrossRef] [PubMed]
  80. Kanwar, S.S.; Ghazi, I.A.; Chimni, S.S.; Joshi, G.K.; Rao, G.V.; Kaushal, R.K.; Gupta, R.; Punj, V. Purification and properties of a novel extra-cellular thermotolerant metallolipase of Bacillus coagulans MTCC-6375 isolate. Protein Expr. Purif. 2006, 46, 421–428. [Google Scholar] [CrossRef] [PubMed]
  81. Gupta, A.; Verma, G.; Gupta, P. Growth performance, feed utilization, digestive enzyme activity, innate immunity and protection against Vibrio harveyi of freshwater prawn, Macrobrachium rosenbergii fed diets supplemented with Bacillus coagulans. Aquac. Int. 2016, 24, 1379–1392. [Google Scholar] [CrossRef]
  82. Heck, J.X.; FLores, S.H.; Hertz, P.F.; Ayub, M.A.Z. Optimization of cellulase-free xylanase activity produced by Bacillus coagulans BL69 in solid-state cultivation. Process Biochem. 2005, 40, 107–112. [Google Scholar] [CrossRef]
  83. Chauhan, S.; Choudhury, B.; Singh, S.N.; Ghosh, P. Application of xylanase enzyme of Bacillus coagulans as a prebleaching agent on non-woody pulps. Process Biochem. 2006, 41, 226–231. [Google Scholar] [CrossRef]
Table 1. Probiotic food supplements containing Bacillus coagulans.
Table 1. Probiotic food supplements containing Bacillus coagulans.
StrainSupplementReference
Bacillus coagulans 15BNutrition essentials Probiotic[27]
B. coagulans and Bacillus subtilis (B. subtilis)NutriCommit[27]
B. coagulans and Saccharomyces boulardiiFlora3[27]
B. coagulansTHORNE[27]
B. coagulansSunny Green Cleansing Green[27]
Bacillus indicus HU36, B. coagulans, Bacillus clausii (B. clausii), Bacillus subtilis HU58Just Thrive[27]
Bacillus indicus, B. subtilis, B. coagulans, Bacillus licheniformis, B. clausiiMegaSporeBiotic[27]
B. coagulansSustenex[26]
B. coagulansNeolactoflorene[26]
B. coagulansGanedenBC30[28]
Table 2. Substances produced by B. coagulans.
Table 2. Substances produced by B. coagulans.
StrainSubstrateProductReference
Bacillus coagulans DSM 2314Wheat strawLactic acid[48]
Bacillus coagulans DSM2314Sugarcane bagasseLactic acid[49]
B. coagulansSorghum waterLactic acid[50,51]
B. coagulansCoffee extractLactic acid[52]
Bacillus coagulans IPE 22Wheat strawLactic acid[53]
Bacillus coagulans LA 204Corn stoverLactic acid[54]
B. coagulansCorn stoverLactic acid[55]
Bacillus coagulans HL-5Corn flourLactic acid[56]
Bacillus coagulans TB/04MediumLactic acid[57]
Bacillus coagulans PS5MediumLactic acid[58]
Bacillus coagulans arr4Granulated sugar and yeast extractLactic acid[59]
Bacillus coagulans JI12Oil palm empty fruit bunchLactic acid[60]
Bacillus coagulans RCS3Mediumβ-galactosidase[61]
Bacillus coagulans KM-1Fermented soybeanα-galactosidase[62]
Bacillus coagulans BL174Mediumα-galactosidase[63]
Bacillus coagulans B49Wheat branα-amylase[64]
Bacillus coagulans BL174MediumLipase[63]
Bacillus coagulans ZJU318MediumLipase[65]
B. coagulansMelon wastesLipase[66]
Bacillus coagulans VKl1Coconut oil cakeLipase[67]

Share and Cite

MDPI and ACS Style

Konuray, G.; Erginkaya, Z. Potential Use of Bacillus coagulans in the Food Industry. Foods 2018, 7, 92. https://doi.org/10.3390/foods7060092

AMA Style

Konuray G, Erginkaya Z. Potential Use of Bacillus coagulans in the Food Industry. Foods. 2018; 7(6):92. https://doi.org/10.3390/foods7060092

Chicago/Turabian Style

Konuray, Gözde, and Zerrin Erginkaya. 2018. "Potential Use of Bacillus coagulans in the Food Industry" Foods 7, no. 6: 92. https://doi.org/10.3390/foods7060092

Note that from the first issue of 2016, this journal uses article numbers instead of page numbers. See further details here.

Article Metrics

Back to TopTop