1. Introduction
In natural conditions, piglet weaning occurs gradually around weeks 12 to 17 of age [
1,
2,
3,
4]. On the other hand, in current breeding systems, techniques like early weaning are usually employed in order to improve the reproductive efficiency of sows, optimize the usage rate of maternity facilities and report better business profit [
5,
6]. In the European Union, the minimum weaning age of pigs is 28 days. However, litters can be weaned at 21 days of age if they are moved to specialized, thoroughly cleaned facilities [
7]. Early weaning negatively affects piglet development because of the weaning stress caused by changes in food and environment [
8,
9,
10,
11], which contributes to a reduction in feed intake and growth performance and an increase in infection susceptibility [
12] during the postweaning phase. Therefore, to optimize the handling of the piglet weaning period and to obtain good performances in this and future phases, three main aspects should be taken into account: environment, feeding and health. In the European Union, three-quarters of the pig meat production takes place in ten countries. The production in these countries shows better organization between specialized breeders and fatteners [
13]. Furthermore, breeders in these countries usually wean piglets on day 21 and house weaned piglets during an intermediate phase or postweaning phase that occurs before the growing phase and goes from 5–6 kg live BW to 20 kg BW.
Many authors have studied the influence of sex on piglet growth; Ref. [
14] found that males grew faster and developed a heavier and fatter carcass; Ref. [
15] observed that females showed less growth potential than males during the growing phase. The authors of [
16] studied the influence of sex on growth before birth and found that male conceptuses grew faster than female conceptuses before the attachment to the uterine lining. Other authors such as [
17] found that sex had no significant effect on evisceration weight, dressing percentage and carcass length in adult pigs. However, there is scarce information available on the influence of sex on piglet growth during the postweaning phase (6–20 kg BW), which is common in countries like Spain.
Nowadays, technologies connected to so-called smart farming are contributing to optimizing livestock housing management, mainly in fields like animal welfare or energy-efficient livestock housing. In this sense, an appropriate mathematical description of animal growth can be used to predict production performance, daily gain, precocity or adult BW, and to improve breeding decision-making in relation to topics like resource utilization or indoor environmental control. Because growth patterns have been subjected to many mathematical analyses, there is a wide variety of functions available for the prediction of animal growth rates across various life stages. The S-shape, or sigmoid shape, is a widely used nonlinear trajectory that allows for the definition of a point of inflexion at which the early growth rate is maximised, and from which growth slows down until there is no growth at all. In addition, sigmoid functions can model growth based on the estimation of parameters that can be readily interpreted and allow for the analysis of features that can differentiate among animal growth patterns [
18]. Generalized logistic functions with a variable point of inflexion, such as the Richards [
19] or Janoschek [
20] functions, are flexible, but the models based on these functions often show convergence issues. Functions with a fixed point of inflexion, such as the logistic function, the Von Bertalanffy function or the Gompertz function, can be more easily applied to BW modelling. Many authors have pointed to a sigmoid-shaped relationship between BW and components such as protein or fat over time, which fits the properties of the Gompertz function at any point in the life cycle of the animal [
21]. In contrast, linear models are more flexible and computationally simpler than nonlinear models and provide a relatively good fit of data to growth curves.
Usually, growth studies are based on longitudinal data, i.e., on measurements repeated on the same individual at different time points. These measurements are correlated with one another, which violates the assumption of independence of errors, a key assumption in many of the techniques used traditionally to model animal growth. A solution to this shortcoming is using mixed effects models that take into consideration the variance–covariance structure of the BW data [
22]. For example, nonlinear mixed growth models can model nonlinear curves considering the changes within and between animals and allow for the assessment of the features of every individual in their growth pattern [
18]. However, the performance of these mixed models to characterize the growth of piglets during the postweaning phase, with high growth rates in relation to weight, is still unknown.
This research aims to characterize the growth rates of piglets throughout the production cycle, from 6 to 20 Kg live BW, and to determine the effect of sex on piglet growth. To this end, the production records and the biological parameters derived from the growth curves are used. Finally, weaned piglet growth is modelled using linear and nonlinear mixed models and the best-fitting curves are chosen.
2. Materials and Methods
On a commercial pig farm located in Northwest Spain, two batches of weaned piglets, one of 50 castrated males (CM) and one of 50 females (FM), were housed in two identical adjacent pens during two postweaning breeding cycles. The piglets, which were Large White × Landrace hybrids, were weaned at 21 days of age and grouped according to sex. All the piglets were weighed at 1-week intervals during two breeding cycles (C1 and C2) of 40 and 38 days, respectively, according to the company’s commercial strategy. Cycle 1 (C1) extended from June 9 to July 19, whereas cycle 2 (C2) extended from February 27 to April 6 of the following year.
The pens, which were described in detail by [
23], were 3.2 × 3.2 m
2 in size and were enclosed with PVC divider panels (
Figure 1). The piglets were fed
ad-libitum in a double wet hopper composed of two 0.6 m-long feed spaces. The pigs were fed a lacto-initiator diet during the first five days after weaning, a pre-starter diet from day 6 to 20 postweaning and a starter diet from day 21 to the end of the cycle (
Table 1), following a gradual transition in diet change. Water was supplied at a nipple drinker placed close to the feeder.
All the piglets in both batches (CM and FM) were weighed weekly from the start to the end of the cycle. Specifically, the piglets were weighed on days 21, 26, 33, 40, 47, 54 and 61 of age in C1, and the piglets were weighed on days 21, 29, 36, 43, 50, 57 and 59 of age in C2. The weighing procedure consisted of introducing small batches of 5 to 10 piglets, depending on their size, into a digital weighing scale for pigs with <+/−0.020% accuracy, model BARRE DI PESATURA MI2000, and recording the weight of each batch. In addition, the following environmental parameters were measured in the animal zone: temperature (TA), relative humidity (HA) and airspeed (AVA). TA and HA were measured using a temperature/HR smart sensor (ONSET S-THB-M002) with a measurement range of −40 °C to 75 °C and accuracies of ±0.2 °C for temperature and ±2.5% for humidity. To measure AVA, a Delta Ohm HD103T.0 hotwire probe with a measurement range of 0–5 m/s and ±0.06 m/s accuracy was used. The 10 min averages of the measured values at 1 s intervals were stored in a HOBO data logger (HOBO-22).
The collected data corresponds to the average weight of the batches of piglets weighed simultaneously on the weighing platform, i.e., the individual weight data are not available. The size of the weighing batches ranged from 10 piglets at week 1 of the cycle to 5 piglets at the last week of the cycle. Accordingly, it would not be reasonable to analyse individual average BWs for n = 50 because BW variability would be underestimated. For this reason, we assumed n was equal to the number of weight measurements for each batch (FM or CM), and the average BW of the batch was assumed to be a single sample, thus reducing the potential problems related to data pseudo replication.
During the breeding cycle, some animals were removed because of health, animal welfare or production-related issues. Specifically, five animals were removed from the CM batch at week 3 of C1 and one at week 4 of C1. Similarly, three animals were removed from the CM batch at week 3 of C2. As per the FM batch, only one animal had to be removed at week 3 of C1. The rest of the piglets reached the end of the cycle in good health and welfare status, and both batches were visually homogeneous. The end of the breeding cycle was established according to commercial requirements, so the piglets ended the stages at 61 and 59 days of age in C1 and C2, respectively.
Statistical Analysis
Given the longitudinal data structure, with repeated measurements on the CM and FM batches throughout each cycle, mixed models provide a good alternative for modelling our data without incurring errors caused by pseudoreplication [
24]. To model piglet growth, linear (quadratic and exponential) and nonlinear (Gompertz, logistic, Richards and Von-Bertalanffy) models were used. The group “sex:cycle” (e.g., CM:C2) was introduced as a random effect in all the models. Similarly, the variable “
day postweaning” was introduced as a predictor variable in all the models. The method proposed by [
18] was used to fit the nonlinear models. The mathematical expressions for the models used in this research follow:
- b.
Exponential model:
where
Yij is the
j-th weight measurement of individual
i,
β0,
β1 and
β2 are the fixed effects,
tj is the day postweaning on which the
j-th measurement was made, α
i is the random effect of individual
I, and
Ɛij is the residual for
i in measurement
j.
- 2.
Nonlinear models
- b.
- c.
- d.
Von-Bertalanffy model [
27]:
with each parameter in the nonlinear models varying between individuals as follows:
and where
Li is the lower horizontal asymptote for individual
i,
Ai is the upper horizontal asymptote for individual
i,
Ki is the rate of approach to the upper asymptote at the point of inflexion for individual
i,
Ti is the point of inflexion at which
Ki reaches its maximum for individual
I and
si is the curve symmetry parameter for individual
i.
γL,
γA,
γK,
γT and
γs are the average values of parameters
L,
A,
K,
T and
s, respectively, for the sample.
The correlation between varying parameters was constrained to zero. The performance of the models was assessed using Akaike’s information criterion (AIC), the Bayesian information criterion (BIC), the root mean square error (RMSE), the correlation coefficient and the R2. Based on the results, the most appropriate models were chosen.
Based on the Gompertz curve, the maximum ADG at the point of inflexion (ADG
max =
A ×
K/e) and the evolution of the ADG over time can be predicted using the following expression [
28]:
The effect of sex on piglet growth was tested using three different methods: (1) by incorporating the variable, sex, into the quadratic and the Gompertz models; (2) by incorporating sex as a predictor variable into a quadratic model that used average daily weight gain (ADG) as the dependent variable; and (3) by applying a paired Student’s t-test to weekly weight records.
The statistical analysis of data was performed using the R statistical software and Rstudio environment [
29,
30]. The “lme4” R package was used for fitting the linear mixed models [
31], whereas the “saemix” R package was used for the nonlinear mixed models [
32].
3. Results
The average BW per piglet was similar for both batches and cycles (
Table 2). The average BW at weaning was 6.86 kg for both sexes, with an average of 6.63 kg for FM and 7.08 kg for CM. By the end of the breeding period, the animals started the fattening phase with an average BW of 19.46 kg for both sexes, with 19.67 kg for the FM and 19.26 kg for the CM. As shown in
Figure 2, the average and maximum weights tended to be higher in C2 than in C1. The observed trend was influenced by the effect of grouping weight measurements by week and of conducting weight measurements on different days postweaning in C1 and C2. Similarly, our results revealed a slight trend for heavier average weights in males than in females in both cycles, especially in C1.
Based on the Student’s
t-test for paired samples, which was performed every week, significant differences (
p < 0.05) were found only between the weight of males and females at weeks 0 and 1 of C2, with CM showing a heavier weight (
Table 3). From week 3 of C2 onwards, differences in weight were not significant. Because of the lack of correspondence in the age of piglets each week between both cycles, a comparison of the average weights obtained by sex for each cycle was not deemed appropriate.
3.1. Mixed Modelling of Growth Performance
In order to model the weaned piglet growth, the weekly average weight data were fitted to linear and nonlinear mixed models (
Figure 3). For the linear models, the age of the animals (days postweaning) was the only independent variable selected. Tests were performed for the incorporation of the variable, sex, as a fixed-effect factor in the quadratic linear mixed model and the Gomperzt nonlinear mixed model. In both cases, the improvement in model performance after incorporating this variable and its interactions was not significant (
p > 0.05). Based on these results and the results of the Student’s
t-tests, it is our conclusion that there are no differences between the growth of males and females. Accordingly, piglet growth was further modelled using a single dataset including both sexes.
Table 4 shows the goodness of fit of the models, with the nonlinear models performing better.
Furthermore, the nonlinear growth models used are designed so that their parameters have a biological interpretation (
Table 5). The value of the lower asymptote represented by parameter
L is interpreted as weight at weaning and is expressed in kg. The upper asymptotic value of growth, determined by the sum of parameters
L + A, is also expressed in kg and is interpreted as the maximum weight of the animal, or adult weight. Parameter
K (day
−1) indicates the daily weight gain in relation to total weight, while the value of parameter
T (day) represents the point of inflexion of the curve, except for the Von-Bertalanffy model, in which it is interpreted as age at the lower asymptote.
The analysis of average daily gain showed a total average of 0.324 kg/day, with average values of 0.330 kg/day in C1 and 0.317 kg/day in C2 for CM. For FM, the average gain was 0.322 kg/day in C1 and 0.326 kg/day in C2. The average growth by sex considering both cycles was 0.323 kg/day for CM and 0.324 kg/day for FM. The growth rate was not homogenous during the fattening period and followed the evolution shown in
Figure 4.
During week 1 postweaning, piglets do not gain weight, and they even may lose some weight during the first 5 days, as is the case for the CM in C1. From that moment on, ADG starts increasing progressively, with an evolution that is similar to a logarithmic progression. After 30 days postweaning, ADG follows an erratic pattern with a progressive decrease in growth rate in C1 and a sharp decrease in C2 after 36 days postweaning, which is rapidly recovered two days after that, reaching a maximum of 0.844 kg/day in the case of FM (
Figure 4).
The growth rate was modelled using a linear mixed model with the variable, cycle:sex, as the random effects variable, and the square of the days postweaning as the fixed effects variable. With this model structure, a singular fit is obtained, which indicates that the model is “overfitted” and that the structure of the random effects is too complex to be supported by the data. Because this is a longitudinal study, with repeated measurements of the individuals, keeping this structure as simple as possible was required on a theoretical level. In addition, incorporating the variable, sex, as a fixed effect in the previous model was not significant.
Figure 4 represents the derivative of weight as a function of time for the Gompertz curve fitted to the study dataset.
3.2. Environment Quality
For the environmental parameters recorded, the measurements of HA and TA stayed broadly within the established recommendations (
Table 6). AVA increased progressively in C1, with a daily average of 0.13 m/s and maximum peaks of 0.37 m/s at week 5. At week 6, AVA increased to an average of 0.18 m/s on day 39 of the cycle, with a maximum of 0.46 m/s. Despite the operation of the ventilation system, which renewed the air inside the building, the TA reached maximum values of up to 34.3 °C during the last week of C1. In C2, the peak AV was 0.53 m/s on day 32 of the cycle, with a daily average of 0.22 m/s during that week. During C2, it was possible to maintain the maximum TA under 30 °C.
A coincidence in time is observed between the peaks of AVA and TA and the decrease in piglet growth rate. In C1, the rate of growth rate slows down during the penultimate week and decreases during the last week, coinciding with the peaks of AV for C1. Similarly, in C2, the high peaks of AV coincide in time with a strong decline in growth rates during week 5 postweaning.
4. Discussion
At the start of the cycle, the weight of the weaned piglets at 21 days of age (6.86 kg) is within the values reported in the recent literature for pigs of different breeds. For example, Ref. [
10] reported a weight of 6.87 kg in
Duroc × Landrace × Large White piglets weaned at 21 days of age. The author of [
33] reported weights of 6.1 kg in
Berkshire piglets weaned at 21 days of age, and Ref. [
34] registered 5.75 kg on day 18, which could be extrapolated to day 21 through linear regression, obtaining 6.49 kg. In CM and FM
Large White piglets weaned at 21 days, Ref. [
35] recorded a weight of 6.8 kg. Logically, weight at weaning is influenced by weaning age, but also by litter size and weight at birth [
36]. In fact, weight at birth, weight at 24 h from birth and the amount of colostrum consumed explain up to 42% of the individual variation in BW for piglets weaned at 21 days of age [
37].
As per weight at the end of the cycle, on day 34 after weaning, Ref. [
10] reported a weight of 15.78 kg in piglets weaned at day 21 of age or 16.90 kg in piglets weaned at 28 days. They also recorded 19.46 kg on day 40 postweaning for piglets weaned at 21 days of age, a similar weight to that found in this work. Furthermore, Ref. [
8] estimated, depending on the weight at weaning, weights from 17.00 and 22.00 kg at 42 days postweaning in piglets that were separated from their mothers at 19 and 21 days of age, respectively. Ref. [
34] tested the influence of age at weaning on the performance of piglets and found weights ranging from 25.8 to 28.2 kg on day 42 postweaning in animals weaned at 21 days of age. The value described in this work is close to the target weight set by [
38] for the postweaning phase, which was estimated at 21.55 kg at 63 days of age.
4.1. Effect of Sex on Growth
Both the
t-tests for related samples and the incorporation of the factor, sex, on the mixed and fixed effects models revealed no significant differences between sexes in the growth of weaned piglets from 6 to 20 kg BW, which is in agreement with the results reported by [
39], who found that sex had no relevant effects on growth after weaning for
Large White × Landrace pigs, except for some interactions between sex and weaning age or weight at weaning. For example, light gilts showed a higher growth rate than light boars during the first week after weaning, but such a difference was not maintained in the case of heavy boars and gilts. However, Ref. [
22] did find faster growths in males than in females using linear mixed models and fixed models in piglets between birth and 8 weeks old. Likewise, Ref. [
33] analysed the growth of pigs of the breed,
Berkshire, between weaning (at an average of 22 days of age) and 73 days of age and reported greater weights and ADG in males and castrated males than in females. These differences were retained throughout the whole production cycle, up to 152 days of age, except for the lactation phase.
As described by [
15] in crossbred
Iberian × Duroc piglets, while the effect of the weight at birth is observed during the whole production cycle, the effect of sex on growth increases with age. Similarly, Ref. [
40] found significant differences in the effect of weight at birth on weight at days 7, 14, 21 and 28 for piglets, but sex was not found to have a significant effect on ADG during 4 weeks of lactation.
During the fattening phase, Ref. [
41] did not find significant differences between sexes in pigs from 39 to 88 days of age (between 7 and 26 kg BW) but found significantly higher ADG and final weight in boars than in females during the finishing phase, between 89 and 123 days of age. The authors of [
42] used mixed models to obtain significant differences in the parameters of growth between barrows, boars and gilts between 61 and 102 days of age. The boars reached a higher mature live weight (parameter A) but with slower growth (parameter K) than the gilts or barrows, but the barrows reached a higher mature live weight than the gilts. Even so, Ref. [
17] did not find differences in ADG between barrows, boars, and gilts during the phases of growing (from 20 to 48 kg) and finishing (from 49 to 96 kg).
It appears that the effect of sex on growth has a clear interaction with age, but the age or weight at which this point of inflexion occurs is yet to be determined. The effects of the interactions between sex and weight at birth/weaning or feeding management are also important in determining growth rates in the postweaning phase.
4.2. Use of Mixed Models to Model Piglet Growth in the Postweaning Phase
During the last few years, mixed models have been widely used to model the growth of domestic animals [
43,
44,
45]. Although there is little difference between the fit of fixed effects models and mixed models, the predictive capacity of mixed models for new observations is better [
22,
42]. It was also proven that a mixed model with the Gompertz growth curve is more suitable than fixed effect models to explain weight gain in pigs [
46], which is in agreement with the results reported in this study. Furthermore, mixed models consider not only the average of the population but also the individual deviations from that average. For this reason, mixed models with the Gompertz growth curve consider more variance as compared to fixed effects models.
The growth curves tested in this study were already broadly used to describe the growth of several livestock species, both with mixed and fixed effects models [
22,
47]. The nonlinear mixed growth models by Von-Bertalanffy, Richards and Gompertz were the models better fitted to the data. The performance of all these models was very similar and improved the performance of linear mixed models during the postweaning phase. It is possible to find studies in the literature that show that some nonlinear growth curves perform better than others for some specific datasets. For example, ref. [
42] found that the mixed model with the Gompertz function was the best for describing and predicting future values of BW for pigs from 88 days of age to slaughter. In contrast, ref. [
22] compared the Gompertz, logistic and Von-Bertalanffy functions using mixed models and obtained a better fit of BW data both for male and female pigs between 8 days and 8 weeks of age, or more with the logistic curve. Ref. [
48] obtained a better fitting curve using the Lopez function in pigs of 14 to 100 days of age as compared to the mixed Gompertz, logistic and Bridges models.
The analysis of the adjusted parameters shown in
Table 5 reveals that every curve was fitted to values between 6.48 and 6.86 kg at the lower asymptote, which represents weight at weaning. Moreover, the maximum rate of growth determined at the point of inflexion of the Gompertz and Richards curves was reached on day 27 after weaning, with an ADG of 0.508 kg/day at that point, according to the Gompertz curve. Conversely, the value of parameter
s (symmetry) of the Richards growth model controls the asymmetry of the slope of the curve before and after the inflexion point [
49]. The value estimated in our study suggests that more than half of the total piglet growth occurs after the point of inflexion (on day 27.35). This confirms that the Gompertz model performs better than the logistic model. Even though the four nonlinear models tested were very similar in terms of performance, ideally the performance of these curves should be analysed on a test dataset that has not been used for the training of the models. The literature review conducted did not point to the availability of nonlinear models that are specific to the productive phase between 6 and 20 kg BW.
It should be taken into account that one of the main fitting parameters in nonlinear growth curves is asymptotic weight, i.e., what is interpreted as the BW of the animal at an adult age. In this case, the registered BWs reach only up to 60 days of age, which is far from the asymptotic weight. Therefore, the models estimate that the upper asymptote of weight (parameters
A +
L) is found between 21.20 kg in the logistic curve and 30.17 kg in the Von-Bertalanffy model. This incorrect assumption can alter the goodness of fit of the models during the last days of the cycle. When approaching the upper asymptote, the growth rate (ADG) of nonlinear models starts declining continuously. This is the case for the Gompertz curve (
Figure 3), which finally reaches a flat growth. This evolution does not describe the real evolution of growth, because the animals will continue to grow beyond the theoretical asymptotic weight, although a decrease in ADG is to be expected during the last days of the cycle, due to the conditions described in the next section.
4.3. Characterization of Growth Rates
The average ADG for piglets between 21 and 61 days old in the two recorded cycles (0.324 kg/day) is within the range reported by [
50] for piglets between 28 and 63 days old, which oscillated between 0.231 and 0.488 kg/day. Similarly, Ref. [
51] obtained an ADG of 0.401 kg/day in piglets between 29 and 70 days of age. The growth rate is determined by a large number of factors, among which are weaning age [
12,
51], BW at weaning [
52], genetics, facilities [
53,
54] or management [
50].
During the first week postweaning, a flat growth rate was reached. The growth rate was even negative in the case of the CM batch during C1. The decline in growth rate is more pronounced for data collected on day 5 postweaning than for data collected on day 8 postweaning, which is usual, especially for early weaning at 21 days of age [
10]. Weaning causes many changes, mainly in diet and environment, which leads to major stress for the piglets. Stress brings about a decrease in feed consumption and ADG and an increased incidence of diarrhoea [
52].
After the first week postweaning, ADG gradually accelerated until week 4 in the cycle. From week two onwards, there was not a clear trend with regard to the evolution of growth. The influence of the environment and the facilities on the animals is the most plausible explanation for such an evolution. Although HA and TA were always maintained within the thermoneutral zone for animals at this age [
55], a high AVA was recorded, which exceeded the 0.15 m/s of maximum airspeed recommended for this age [
56]. These air currents could have affected the growth of the animals. In general terms, Ref. [
57] described losses in ADG with airspeeds of 0.11–0.40 m/s, especially in younger animals [
58]. Therefore, both an excess of and a deficiency in the air exchange rate could have a great impact on the growth performance of the animals.
Moreover, despite the compliance with the requirement of 0.20 m
2/piglet up to 20 kg included in [
7], the free space per animal available and the limited linear meters of trough per animal constrained the growth of piglets [
54] during the last weeks of the productive period. The piglets experienced an increase in density in the building from 33.5 kg/m
2 at the start of the cycle to an average of 90.0 kg/m
2 at the end of the cycle. Ref. [
59] described a decrease in ADG of around 36 g/day for piglets aged 15 to 71 days and housed at a density of 0.21 m
2/animal, as compared to piglets housed at a density of 0.63 m
2/animal. The equation used to determine the space available was the allometric equation, A = C × BW
0.667, where A is the space available, and C is the coefficient of the space available. Using this equation, an average value of 0.0287 was obtained at the end of the cycles. This value is below the threshold of 0.0335 established by [
60] for piglets from 6 to 20 kg, under which a decrease in growth rates occurs. In the facilities used in this study, the space available around the trough was 2.4 cm/pig, whereas Ref. [
61] obtained higher ADG with 4.3 cm/pig, as compared to 3.2, 2.6 and 2.1 cm/pig for piglets weaned at 21 days of age.