1. Introduction
Extending the laying period of hens is an important way to increase the economic benefits of laying-hen production, which is seriously limited by the decreased laying rate and deteriorated egg quality, especially the poor eggshell quality, in the later stage of the laying cycle. A long and intense laying period usually leads to a general deterioration in the health of the hens [
1], such as the gradual loss of structural bone, specifically cortical bone, whose sacrifice promotes the formation of medullary bone to provide calcium for the formation of eggshells [
2]. The decline in bone quality is manifested as bone deformation, fracture, osteoporosis, cage fatigue, etc., especially in the case of insufficient dietary calcium and phosphorus intake [
3,
4]. About 30% of laying hens with osteoporosis have fractures [
5]. Compared with healthy ones, laying hens with severe osteoporosis lose weight, bone calcium reserves lose 15–20%, and egg production decreases by 18% [
6]. Therefore, improving the quality of eggshells and bone by increasing the calcium utilization rate is the key to delaying the elimination of old laying hens and enlarging the economic benefits of egg production.
Based on the physiological and biochemical changes in laying hens, the demand for calcium in laying hens gradually increases along with age. Feeding a diet low in calcium (1.5%) for 4 weeks at the peak of egg laying increased the egg breaking rate, decreased the feed intake and laying rate after 8 weeks, and reduced the weight and bone weight of laying hens after 12 weeks [
7]. The increase in dietary calcium content from 3.5% to 4.5% in the late laying period improved the eggshell quality and breaking strength of eggs [
8]. During eggshell formation, mineral precursors of calcium ions and HCO
3− ions are continuously supplied from plasma through the epithelial transport of uterine adenocytes [
9]. Therefore, improving the calcium bioavailability of laying hens is one effective way to improve the quality of eggshells.
In the late laying phase of laying hens, inorganic trace elements can be effectively replaced by low levels of compound organic trace elements [
10]. A positive effect was observed in the productive performance, eggshell quality, and eggshell ultrastructure of laying hens fed diets supplemented with organic trace minerals [
11,
12]. At low levels, the replacement of inorganic trace minerals with organic trace minerals could improve the bioavailability of copper, zinc, iron, manganese, chromium, and calcium and the immunity of laying hens [
13,
14]. The dietary inclusion of the organic forms of Zn, Mn, and Cu at a dosage of 50% to 75% lower than NRC recommendations is sufficient to maintain laying performance and can improve the eggshell and albumen qualities of the eggs from laying hens [
15]. Appropriate organic zinc (40 mg/kg) was added to the diet of laying hens to promote the apparent digestion of minerals and nutrients, trace element deposition, and mitochondrial mRNA expression [
16]. Organic ferrous glycinate replaced inorganic ferrous sulfate, which is more beneficial to egg quality and iron enrichment, and does not affect the production performance of laying hens [
17]. Based on a quadratic regression analysis of egg production performance, egg quality, egg iron content, and blood biochemical indexes, the optimal level of Fe-lys-glu to replace FeSO
4 in laying-hen diets was 45 mg Fe/kg [
18]. It can be seen that the use of organic mineral trace elements can effectively increase the bio-utilization rate compared with using the inorganic form. Therefore, the development of suitable and efficient organic calcium is of importance for improving eggshell quality.
During the later stages of the laying cycle, the addition of calcium propionate and calcium butyrate to the diet of laying hens could improve eggshell quality [
19]. As another source of organic calcium, calcium lactate is often used as a food additive to improve antioxidant properties and extend the shelf life of food [
20]. Meanwhile, the safety of lactic acid and calcium lactate at appropriate concentrations has been demonstrated with technological additives in feed for all animal species [
21]. From the above, it can be hypothesized that calcium lactate has great potential to be used in layer feed to improve the bioavailability of calcium and improve the quality of eggshells, which will be verified in the present study from the perspective of the laying performance, blood index, shinbone quality, jejunal immunity, and egg quality of aged laying hens.
2. Material and Methods
2.1. Experimental Design and Bird Management
A total of 360 62-week-old Hy-Line Brown laying hens were randomly divided into 4 experimental treatments, with 6 replicates and 15 chickens per replicate. The birds were managed according to the Hy-Line International Online Management Guide (2011) and the farm’s own experience. Prior to the trial, chicks were given free access to water and a commercial corn–soy-based layer diet. The control diet was prepared in accordance with the nutritional requirements of the National Research Council of the United States (NRC, 1994) and the Chinese Chicken Feeding Standards (NY/T 33-2004) [
22]. The formula and nutritional levels of the basic diet are shown in
Table 1. Calcium lactate, a commercial product with a purity of over 99%, was used in the present study. Each treatment group was fed with 0.25%, 0.5%, and 1.0% calcium lactate to substitute limestone (maintaining the same amount of calcium) in the control diet, and the mass increase caused by different molecular weights of the two calcium sources during substitution was balanced by decreasing the amount of zeolite powder. The calcium sources of each treatment group are shown in
Supplementary Table S1. The pre-test period was 1 week to allow the chicks to gradually adapt to the change from commercial layer feed to trial feed.
During the feeding trial, all birds were housed in three-tier A-type cages in an environmentally controlled room with 3 birds per cage (40 cm × 40 cm × 35 cm) with 16 h of light per day. The room temperature was kept at 15–25 °C. The feeding experiment was conducted for 12 weeks, and the egg number, egg weight, abnormal egg number, and mortality of hens per replicate were recorded every day. The feed consumed by each replicate was recorded weekly. Average daily feed intake, average daily egg mass, average egg weight, and feed conversion ratio were calculated.
2.2. Sample Collection and Organ Index Measurement
At weeks 2, 4, 8, and 12 of the trial, five normal eggs were selected for each replicate. One hen per replicate was taken at the end of the experiment. The chicks were fasted for 12 h, 5 mL of wing vein blood was taken in a vacuum blood-collecting vessel with heparin anticoagulant, 7 mL was taken in a vacuum blood-collecting vessel without anticoagulant, the latter was centrifuged at 3000× g r/min for 15 min at room temperature, and serum was taken and stored at −20 °C. Selected birds were dissected under sterile conditions after bleeding from the neck. We weighed the pancreas, spleen, leg muscle, and shinbone of the birds and calculated their relative weight based on the ratio of their weight (g) to BW (g). The small intestine was excised and frozen immediately. The jejunum mucosa was scraped and stored at −20 °C.
2.3. Quality Detection of Egg and Shinbone
We separated the albumen and yolk for each egg and weighed them separately. After natural drying for 3 days, the albumen residue was removed and the eggshell was weighed. The weight proportions of albumen, yolk, and shell in the whole egg were calculated. The thickness of the eggshell was detected on the egg surface with an Eggshell thickness Gauge (ESTG1, Orka Technology Ltd., Ramat Hasharon, Israel) at 3 locations to obtain an average value, including the air chamber, the equator, and the tip. The measurement of eggshell strength was performed with an Egg Force Reader (Orka Technology Ltd., Ramat Hasharon, Israel). An egg analyzer (Orka Technology Ltd., Ramat Hasharon, Israel) was used to detect albumen height, Haugh units, and yolk color. The force parameters of the shinbone were measured using a texture analyzer (TMS-PRO, Food Technology Corporation, Mecmesin Ltd., Brighton, UK).
2.4. Chemical Analysis
Routine blood examination of anticoagulant blood samples was conducted using a fully automatic hematology analyzer (XP-100, Kobe, Japan, Sysmex Corporation). Jejunal mucosa was homogenized before testing. Biochemical parameters of serum and jejunal mucosal were detected with the ELISA method by an automatic biochemical analyzer (Model 7020, Hitachi, Tokyo, Japan) using commercial kits purchased from Nanjing Jiancheng Bioengineering Institute (Nanjing, China). The former included total protein, albumin, globulin, total cholesterol, triglyceride, high-density lipoprotein, low-density lipoprotein, creatinine, urea, aspartate aminotransferase, alanine transaminase, total bilirubin, creatine kinase, calcium, and phosphorus. The latter included immunoglobulin A (IgA), immunoglobulin M (IgM), immunoglobulin G (IgG), interleukin 2 (IL-2), interleukin 6 (IL-6), tumor necrosis factor α (TNF-α), and secretory immunoglobulin A (sIgA). The product information of kits used in the current study is listed in
Supplementary Table S2. And the detection was strictly performed according to the manufacturer’s instructions.
2.5. Statistical Analysis
Experimental data were analyzed using one-way ANOVA and Duncan’s multiple comparisons of SAS 9.2 (SAS institute. Inc., Cary, NC, USA). p ≤ 0.05 means significance.
4. Discussion
The decline in eggshell quality is one of the biggest challenges in feeding old laying hens and causes large economic losses in egg production and processing. As a kind of organic calcium, calcium lactate showed a higher true digestibility coefficient of calcium than limestone, calcium phosphate, bone meal, and egg powder in pigs [
23]. Lactic acid and calcium lactate are safe to add to animal feed [
21], and the production cost of feed-grade calcium lactate is gradually reduced and widely used. Therefore, calcium lactate in feed is expected to improve the calcium utilization of elderly laying hens, enhance the eggshell quality, and prolong the effective laying period of hens.
Feed addition of 0.5% sodium butyrate and 0.5% calcium propionate reduced the feed cost of eggs without affecting the quality of the eggs [
24]. The addition of benzoic acid products to free-range diets can reduce the negative impact of forage on nutrient utilization and improve the digestibility of ileal nutrients [
25]. Compared with sodium selenite, organic selenium integrated with bacteria or yeast improved the performance, egg quality, and selenium contents of tissues and eggs and increased beneficial caecal bacterial proliferation and butyric acid content in laying hens [
26,
27]. The addition of organic sulfur and inorganic sulfur to the diet was beneficial to the ileal morphology and antioxidant capacity of laying hens [
28]. It can be seen from the above that the addition of organic acids and organic elements to feed can effectively improve the production of laying hens, which was confirmed again in this study, which showed that the addition of calcium lactate to feed improved the egg-production performance of laying hens.
The continuous extension of the commercial production cycle has caused an imbalance in the utilization of calcium and phosphorus in older laying hens, often causing bone fractures and poor eggshell quality [
29,
30]. Compared with inorganic mineral elements, dietary supplementation with organic sources increased their bioavailability and improved egg quality during the late production stage of laying hens [
10,
14]. Organic acids can be used as antimicrobial molecules or health promoters in the feed of poultry and also increase the digestibility of nutrients [
25,
31]. In addition, dietary supplementation with organic acids in combination with phytase can increase the calcium–phosphorus utilization of laying hens [
32]. In this study, the contents of calcium and phosphorus in serum were increased by the dietary addition of calcium lactate. Calcium and phosphorus homeostasis, which are directly related to the components required for eggshell calcification and bone mineralization, ultimately affect eggshell quality [
29]. Therefore, it can be deduced that the dietary organic calcium lactate in the current study improved the shinbone, eggshell, and albumen quality of laying hens probably through increasing calcium bioavailability and intestinal nutrient absorbability.
The red blood cell count has proven to be one of the most commonly used blood tests and plays a vital role in determining overall health, which is valuable for the early diagnosis of some diseases [
33]. Lower mean corpuscular hemoglobin concentration is associated with a poor surgical prognosis for several diseases [
34,
35]. Heterophils are the most abundant immune cell in the blood, and are mainly used to defend against pathogens [
36]. Mononuclear leucocytes, the largest white blood cells, are an important component of the body’s defense system. Basophilic granulocytes are mainly found in the blood, and will be induced by chemokines to migrate to tissues in the presence of inflammation [
37]. In the current study, the dietary inclusion of calcium lactate increased the contents of red blood cells, corpuscular hemoglobin, mononuclear leucocytes, and basophilic granulocytes and decreased the number of heterophils. This indicated that calcium lactate could improve the aerobic capacity and hematogenic immunity of laying hens, which may be part of an explanation for improving the quality of eggshells and albumen. ALT is one of the most important indicators of liver function, and its elevated concentration in the blood indicates liver damage [
38]. Serum creatine kinase is an enzyme that is commonly used in clinical practice to assess the diagnosis and monitoring of muscle injuries, myocardial injuries, and other diseases [
39]. In this study, the concentrations of ALT and creatine kinase in serum were decreased by experimental treatments, so it demonstrates the positive effects of calcium lactate on the liver and muscle health of animals.
Immunoglobulins play a fundamental role in the body’s protection against internal and external threats [
40]. Lysozyme is a 1,4-beta-
N-acetylmuramidase with antimicrobial properties. Dietary lysozyme supplementation contributes to enhanced intestinal functions and gut microflora in piglets [
41,
42]. In the current study, the concentrations of IgA, IgG, lysozyme, and sIgA in the jejunal mucosa of laying hens were observably increased by experimental treatments, and that of IL-2, an important pro-inflammatory factor, was decreased. Diets with organic acids could maintain intestinal morphology and could promote digestion, absorption, and barrier function [
43]. The weight index of the pancreas, the largest intestinal digestive enzyme-secreting organ, was increased in laying hens fed calcium lactate. Therefore, it shows that dietary calcium lactate could improve the intestinal digestible ability and jejunal mucosal immunity of laying hens, which is probably a potential reason for the improvement in laying performance.