Search Results (14)

This study evaluated how fruit fermentation liquid (FFL) enhances the conversion of chicken manure by black soldier fly larvae (BSFL) and modulates their gut microbiota. Three groups were tested: control (A: 300 g manure + 50 g water), low-dose FFL (B: 300 g manure + 25 g FFL + 25 g water), and high-dose FFL (C: 300 g manure + 50 g FFL). The results show that the dry matter conversion rate significantly increased by 9.5% (p < 0.05), while the feed-to-larvae ratio was reduced by 1.02 (p < 0.01) in group C. NH₃ emissions in group C decreased by 24.48 mg·kg⁻¹·DM (dry matter substrate) day⁻¹ (24.48 mg per kilogram of dry matter substrate per day) (p < 0.01), with suppressed H₂S release. Gut microbiota analysis revealed that FFL reduced the abundance of Proteobacteria (6.07% decrease in group C) while enriching Actinobacteriota (4.68% increase) and beneficial genera (Corynebacterium, Gallicola). Substrate microbial diversity in group C improved, with Proteobacteria and Firmicutes increasing by 11.07% and 4.83%, respectively, and pathogenic Sphingobacteriaceae declining by 21.16% by day 7. FFL likely introduced organic acids and nutrients, enhancing larval digestion and nutrient absorption while inhibiting the production of harmful gases. These findings demonstrate that FFL optimizes BSFL-driven waste conversion efficiency through modulation of the microbiota, offering a sustainable strategy for organic waste management and contributing to circular agricultural systems. Full article

Platforms have been shown to be a suitable environmental enrichment for broiler chickens, accommodating their motivation to roost and rest at an elevated position. In order to increase the animal welfare benefits, we designed prototype elevated platforms with additional functionalities: a local cooling system, a sheltered area underneath the platform and collection trays underneath the platform that prevent manure from falling on the litter. This study assessed the effects of these multifunctional platforms during thermoneutral and heat stress conditions on two key determinants of their commercial uptake potential, namely production performance, carcass and meat quality. In each of the three experimental rounds, 560 one-day-old male chicks (Ross 308) were equally assigned to four pens and reared for 43 days. The barn was divided into two compartments (thermoneutral and heat), each containing one enriched and one barren pen. To induce heat stress, the ambient temperature was increased to 32 °C during 6 h/day when the birds were 29–40 d old. The platforms did not compromise broiler performance. Heat stress negatively impacted body weight (p = 0.008), average daily gain (p = 0.009) and feed intake (p < 0.001) and improved the feed conversion ratio (p = 0.026). The platforms reduced mortality rate under heat stress but not under thermoneutral conditions (heat × enrichment p = 0.025), likely due to the cooling functionality. No major effects of the platforms on overall carcass and meat quality were observed, except for a reduction in the risk of breast muscle myopathies (p < 0.001), which could enhance consumer acceptance and improve profitability. To conclude, the use of cooled platforms under the conditions of this experiment mitigated the adverse effects of heat stress on mortality, reduced the risk of breast muscle myopathies and did not compromise any other production or carcass and meat quality parameters. Full article

Wheat straw (WS) has long been subjected to rough treatment by traditional incineration, which not only results in the waste of biomass resources but also poses a risk of atmospheric pollution and is not conducive to the sustainable utilization of natural resources. With great humification potential, WS can be utilized as a valuable composting material. The study optimized the C/N ratio by mixing WS and chicken manure (CM) as composting raw materials, and found that this method could significantly improve the compost quality. In comparison to the conventional poplar woodchip (PW) conditioning, the incorporation of WS resulted in an elevated composting temperature, an extended high-temperature period, a more expeditious lignocellulose degradation, a notable enhancement in the organic matter content, a suppression of hydrogen sulfide production under low C/N ratio, and a promotion of elemental sulfur conversion, collectively contributing to an enhanced overall quality and environmental friendliness of the compost. Correlation analysis of microbial communities and environmental factors demonstrated that the mixed compost facilitated the growth of actinomycetes and sulfur-transforming bacteria. Additionally, structural equation model indicated that parameters such as temperature and pH value played a key role in the composting process. Full article

This study investigated the impacts of biochar addition on N conversion, humification, and bacterial community during Flammulina velutipes waste composting. The mixture of chicken manure and Flammulina velutipes waste was 4:6 (dry weight basis). The biochar was added into the mixture and mixed thoroughly at ratios of 0, 2.5, 5, and 7.5% (w/w) and labeled as CK, T1, T2, and T3, respectively. The results showed that the biochar treatment significantly improved the compost maturity by increasing humic substances and the conversion of NH₄⁺-N to NO₃⁻-N. With the increase in biochar supplemental level, the abundance, diversity, and uniformity of the microbial community were improved. The dominant taxa were Firmicutes, Bacteroidota, Actinobacteriota, Proteobacteria, and Gemmatimonadota, especially the Firmicutes and Bacteroidota. Biochar addition facilitated the proliferation of thermophilic bacteria such as Bacillus, Actinobacteriota, Parapedobacter, and Sphingobacterium, leading to enhanced organic decomposition to increase humus. The findings of this study highlighted the positive effects of biochar addition on the composting mixture of chicken manure and Flammulina velutipes waste. These results can help to produce high-quality biochar composting products by balancing organic decomposition and humification based on the bacterial community. Full article

Supplementation of alternative carbon sources is a technological bottleneck, particularly in post-denitrification processes due to stringent effluent nitrogen levels. This study focuses on enhancing the sustainability of wastewater treatment practices by partially replacing conventionally used fossil-derived methanol with organic waste-derived volatile fatty acids (VFAs) in moving bed biofilm reactors (MBBRs). In this regards, results of denitrification batch assays with sequential or simultaneous addition of VFA effluent from acidogenic fermentation of potato starch residue (AD-VFA_PPL) and chicken manure (AD-VFA_CKM), simulated synthetic VFAs solutions (sVFAs), and methanol as carbon source were presented and discussed. Although methanol has proven superior in the conversion of nitrate to nitrite, VFAs are more effective when it comes to reducing nitrite. Although solely added AD-VFA_PPL had a slower denitrification capability (0.56 ± 0.13 mgNO_x-N removed/m²/day) than methanol (1.04 ± 0.46 mgNO_x-N removed/m²/day), up to 50% of the methanol can be replaced by waste-derived AD-VFA_PPL and achieve comparable performance (1.08 ± 0.07 mgNO_x-N removed/m²/day) with the pure methanol. This proves that the co-addition of VFAs together with methanol can fully compete with pure methanol in performance, providing a promising opportunity for wastewater treatment plants to potentially reduce their carbon footprint and become more sustainable in practice while benefiting from recovered nutrients from waste. Full article

The valorization of chicken manure via pyrolysis can give biowaste a second life to generate value and contribute to the circular economy. In the present study, the thermal degradation and pyrolysis characteristics of chicken manure pyrolysis were investigated via thermogravimetric analyses (TGA) coupled with optimization methods. Thermogravimetric data were obtained for the samples at five heating rates of 5, 10, 20, 30 and 50 °C/min over a range of temperature under inert conditions. The manure devolatilization process was initiated at between 328 and 367 °C to overcome the global activation energy barrier. The determined activation energy of the manure via Flynn–Wall–Ozawa (FWO), Kissinger–Akahira–Sunose (KAS), Friedman and Kissinger methods was in the range of 167.5–213.9 kJ/mol. By using the particle swarm optimization (PSO) method, the pyrolytic kinetic parameters of the individual component present in the manure were calculated, in which the activation energy for cellulose (227.8 kJ/mol) was found to be higher than that of hemicellulose (119 kJ/mol) and lignin (134.3 kJ/mol). Based on intrinsic transition-state theory, the pre-exponential factor and activation energy of the manure can be correlated through a linear equation ln A_α = 0.2006 E_α − 1.2847. The devolatilization characteristics of the chicken manure were elucidated via the optimization process, paving the way for the design of thermochemical conversion reactors and processes. Full article

The global increase in population will result in increased global food production which can, in turn, lead to excessive food waste. Although composting is widely adopted for the conversion of organic waste into value-added products, there are several limitations, such as its lower efficiency in composting food waste without co-composting, the loss of nutrients, and the emission of greenhouse gases. Due to its renowned characteristics, biochar amendments are used during composting to overcome these issues; each waste should be at an appropriate level to yield good quality compost with high nutrient levels. In this study, we co-composted food waste with chicken and swine manure with varying proportions in the presence and absence of biochar to identify the ideal proportion of each raw material and the biochar. Physicochemical parameters such as pH, EC, temperature, bulk density, porosity, C:N ratio, and gaseous emissions were analyzed. The results showed that the desired quality of compost was obtained in the treatment with 5% biochar with 40%, 20%, and 20% of food waste, chicken manure, and swine manure, respectively, and 15% sawdust. Full article

The rapidly growing population has increased demand for protein quantities and, following a shortage of plant-based feed protein sources and the prohibition of animal-based feed protein, has forced the search for new sources of protein. Therefore, humans have turned their attention to edible insects. Black soldier fly larvae (BSFL) (Hermetia illucens L.) are rich in nutrients such as fat, protein and high-quality amino acids and minerals, making them a good source of protein. Furthermore, BSFL are easily reared and propagated on any nutrient substrate such as plant residues, animal manure and waste, food scraps, agricultural byproducts, or straw. Although BSFL cannot completely replace soybean meal in poultry diets, supplementation of less than 20% has no negative impact on chicken growth performance, biochemical indicators and meat quality. In pig studies, although BSFL supplementation did not have any negative effect on growth performance and meat quality, the feed conversion ratio (FCR) was reduced. There is obviously less research on the feeding of BSFL in pigs than in poultry, particularly in relation to weaning piglets and fattening pigs; further research is needed on the supplementation level of sows. Moreover, it has not been found that BSFL are used in ruminants, and the next phase of research could therefore study them. The use of BSFL in animal feed presents some challenges in terms of cost, availability and legal and consumer acceptance. However, this should be considered in the context of the current shortage of protein feed and the nutritional value of BSFL, which has important research significance in animal production. Full article

Anaerobic digestion (AD) of organic waste is considered a sustainable solution to energy shortage and waste management challenges. The process is facilitated by complex communities of micro-organisms, yet most wastes do not have these and thus need microbial inoculation using animal manures to initiate the process. However, the degradation efficiency and methane yield achieved in using different inocula vary due to their different microbial diversities. This study used metagenomics tools to compare the autochthonous microbial composition of cow, pig, chicken, and horse manures commonly used for biogas production. Cows exhibited the highest carbon utilisation (>30%) and showed a carbon to nitrogen ratio (C/N) favourable for microbial growth. Pigs showed the least nitrogen utilisation (<3%) which explains their low C/N whilst horses showed the highest nitrogen utilisation (>40%), which explains its high C/N above the optimal range of 20–30 for efficient AD. Manures from animals with similar gastrointestinal tract (GIT) physiologies were observed to largely harbour similar microbial communities. Conversely, some samples from animals with different GITs also shared common microbial communities plausibly because of similar diets and rearing conditions. Insights from this study will lay a foundation upon which in-depth studies of AD metabolic pathways and strategies to boost methane production through efficient catalysis can be derived. Full article

Insects can play an important role to upgrade waste streams into high-grade proteins and fats as food and feed ingredients or non-food products. The aim of this research was to assess the feasibility to use waste streams with a low value for direct application as animal feed as substrates to grow BSF larvae in terms of larval growth rate, waste reduction index, and efficiency of conversion of ingested feed. The growth of black soldier fly (BSF), Hermetia illucens larvae and conversion of biowaste was assessed in triplicate in biowaste substrates: chicken feed (CF; reference diet), pig manure solid (PMS), Betafert^® solid (BTFS), swill (SW), olive pulp (OP), pig manure liquid mixed with chicken feed (PMLCF), and silage grass (SG). Per kilogram fresh substrate 2500 starter (8-days-old, second instar) larvae were incubated in 21 plastic containers (75 × 47 × 15 cm). The BSF larvae were fed according to a batch feeding system. Highest growth rate was found in larvae reared on SW (13.4 mg/d). Larval growth rate was even higher than in larvae reared on the reference substrate CF (7.2 mg/d). Growth rate in larvae reared on PMLCF (7.3 mg/d) did not differ from CF, whereas growth rate of larvae reared on PMS (3.2 mg/d) was lower than on CF. Growth rate of larvae reared on BTFS, OP and SG was very low (0.6, 0.2 and 0.7 mg/d, respectively). Waste Reduction Index (WRI) was highest on SW (11.3), followed by PMLCF (9.3), and both were higher than WRI on CF (8.5). Waste Reduction Index further decreased in descending order from PMS, SG, BTFS to OP (7.6, 4.0, 2.9 and 1.7, respectively). The Efficiency of Conversion of Ingested substrate (ECI) was highest on SW (0.31), followed in descending order by PMLCF, CF and PMS (0.25, 0.21 and 0.18, respectively). The substrates OP, BTFS and SG (0.16, 0.15 and 0.14, respectively) resulted in a lower ECI than other substrates. Highest CO₂ and lowest NH₃ concentrations were found above substrates with the highest larval growth performances. This study showed that BSF larvae can be reared on different biowaste substrates; the growth rate of the larvae was extremely high on SW. The effects of chemical composition and physical properties of the substrates on larval growth and gas emissions should be further considered. Full article

Studies have focused on identifying combinations of insects and organic waste to optimise bio-conversion. Here, the effects of different diets (10% chicken feed complemented with 90% vegetable waste, garden waste, cattle manure, or horse manure) on growth and survival rates, and nutritional value of Zophobas morio and Tenebrio molitor larvae, and Acheta domesticus were investigated. Compared with chicken feed, organic waste decreased the individual larval weight, although green waste showed fewer negative effects than the manure. The macronutrient concentrations in garden waste were moderate compared with chicken feed, and vegetable waste was the poorest diet in terms of nutrient concentration, as revealed by the principal component analysis (PCA). There was no difference in weight between larvae reared on garden waste and those reared on vegetable waste. Tenebrio molitor and A. domesticus showed the maximum growth rates at 71–101 and 36–66 days of age at 22.5 ± 2.5 °C, respectively. The PCA showed that the protein and fibre concentrations were inversely proportional to fat concentration in the larvae. Acheta domesticus was rich in proteins, whereas Z. morio and T. molitor were rich in fat. Feeding nutrient-poor diets resulted in a lower protein and a higher fat concentration in the larvae. Full article

The aim of this research was to evaluate the effect of biochar diet supplementation for broiler chickens on (1) ammonia and odor emissions from manure, (2) feed conversion ratio and daily weight gain, and (3) selected meat quality and sensory parameters. Beechwood biochar (BC, 2 and 4%) and BC–glycerin–aluminosilicates mix (BCM, 3 and 6%) were tested as dietary additives. A total of 750 chicken broilers (Ross 308) were divided into five dietary groups with five replicates per group (n = 5, 30 birds in each replicate) and reared on a littered floor for 5 weeks. Both feed additives showed a significant reduction of ammonia emissions by up to 17%, while the reduction of odor emissions was not statistically significant. The feed conversion ratio increased by 8% for the highest concentration of the mixture. The change of the treated broilers’ average body weight ranged in the last week of the experiment from 0 to −7%, with the most negative effect for the highest dose of the mixture. Sensory analysis of the sous-vide cooked breasts showed no significant differences. Full article

Carbonization of cage layer chicken manure (CLCM) can improve its bio-recalcitrance which might improve nitrogen (N) bioavailability in soil. However, temperature(s) to exhibit appropriate variations in the chemical makeup of the manure during carbonization in order to achieve this objective is unknown. In this study, we investigated the alterations in chemical compositions, surface functionalities, and N speciation initiated by different carbonization temperatures (350, 500, and 650 °C) and the effects of these alterations on N bioavailability in soil. The objective was to identify suitable temperature condition(s) for the conversion of CLCM into a carbonized product of appropriate bio-recalcitrance that is capable of improving N bioavailability in soil more than the un-carbonized CLCM. The results showed an increased bio-recalcitrance of the manure with increasing carbonization temperatures due to drastic changes in the chemical makeup and accumulation of heterocyclic aromatic N structures. Subsequently, these alterations in the chemical makeup and state of the organic N species in the manure affected N bioavailability in soil. Notably, N bioavailability of CLCM and benefits on plants were improved when soil was supplied with CLCM that was altered at 350 °C. With these observations, we concluded that alterations in chemical and surface structural compositions and N speciation at 350 °C are optimum for instituting the required bio-recalcitrance to CLCM in order to improve N bioavailability in soil for plants. Full article

Animal waste, including chicken manure, is a category of biomass considered for application in the energy industry. Poland is leading poultry producer in Europe, with a chicken population assessed at over 176 million animals. This paper aims to determine the theoretical and technical energy potential of chicken manure in Poland. The volume of chicken manure was assessed as 4.49 million tons per year considering three particular poultry rearing systems. The physicochemical properties of examined manure specimens indicate considerable conformity with the data reported in the literature. The results of proximate and ultimate analyses confirm a considerable effect of the rearing system on the energy parameters of the manure. The heating value of the chicken manure was calculated for the high moisture material in the condition as received from the farms. The value of annual theoretical energy potential in Poland was found to be equal to around 40.38 PJ. Annual technical potential of chicken biomass determined for four different energy conversion paths occurred significantly smaller then theoretical and has the value from 9.01 PJ to 27.3 PJ. The bigger energy degradation was found for heat and electricity production via anaerobic digestion path, while fluidized bed combustion occurred the most efficient scenario. Full article