1. Introduction
The onset of lactation is a critical period for high-production dairy cows, when many physiological and nutritional changes tend to occur. A negative energy balance is considered to be a significant hazard facing dairy cows during this period. Therefore, increasing diet energy content may limit the length and severity of this negative energy balance while maintaining milk yield in high-lactating dairy cows. Feeding high-yielding cows with rumen-bypass fats increases the energy content of the diet without the need to increase the starch content or decrease the fiber intake [
1]. This avoids disruption of rumen functions [
1]. Diet supplementation with fat affects milk yield [
2], milk fat [
3], and days in milk (DIM) [
4]. These effects may depend upon the nature of the fat supplement, how it is processed, and the quantity of fat added to the diet [
5].
Linseed is rich in unsaturated fatty acids, as its oil contains approximately 55% α-linolenic acid (ALA) [
6]. In ruminant nutrition, when supplementing with unprotected fats, ruminal losses of unsaturated fatty acids can be quantified. These fatty acids undergo a rumen biohydrogenation process before intestinal absorption. This is because the oily nature of these fatty acids interfere with the ruminal microorganism ecosystem [
7]. In this respect, Jenkins [
8] and Palmquist [
9] summarized the ways in which the oily nature of fats may affect microorganisms in the rumen. Initially, fats may be adsorbed onto the bacterial membrane surfaces, consequently lowering microbial activity. This reduces the supply of minerals, such as calcium and magnesium, required for the fermentation activity in the rumen, by the formation of calcium and magnesium soap. In addition, this added fat-antimicrobial effect may be linked to the potential toxicity of various polyunsaturated fatty acids (PUFAs), particularly in cellulolytic bacteria. Indeed, adding polyunsaturated fatty acids to the ruminant diet leads to the formation of many intermediate products created during rumen biohydrogenation. These products include trans-fatty acids and conjugated linoleic acid (CLA) precursors, which may decrease the milk fat percentage [
10]. Therefore, the quantity of absorbed PUFAs from the small intestine depends primarily on the degree that PUFAs are protected against ruminal biohydrogenation [
11].
Oilseed extrusion is a heat-treatment process for seeds used in ruminant feed. The heat treatment aims to protect unsaturated fatty acids from ruminal biohydrogenation and to safeguard the rumen environment from the adverse effects of fats [
12]. Heat treatment of oilseeds denature the proteins, which surround lipid molecules, and consequently reduce ruminal biohydrogenation of fats (and associated unsaturated fatty acids) by rumen microorganisms [
11]. Another theory relating to the protection of PUFAs against ruminal biohydrogenation postulates that oilseed extrusion raises the oil release level in rumen fluid [
13], and thus leads to greater postruminal fat absorption in comparison to untreated oilseed [
14].
Despite there being numerous studies on the effects of extruded linseed [
11,
12,
15,
16,
17] and extruded soybean [
18,
19,
20] on ruminant feeding, three main questions persist. Firstly, most research findings in this area are contradictory. Secondly, little information is available in relation to the impact of extracted oilseed supplementation on mastitis incidence and reproductive performance. Thirdly, knowledge is limited in relation to the effects of feeding a mixture of extruded linseed and soybean (ELS) on lactation performance, fatty acid profiles, mastitis incidence, and reproductive performance.
Many studies on dairy cows have verified that PUFAs from plant sources have favorable activities as modulators of the immune and inflammatory responses [
21,
22,
23]. Importantly, a negative correlation exists between immune traits and mastitis prevalence [
24]. Therefore, based on the previously reported immunomodulatory effects of both extruded oilseeds [
25,
26], we hypothesize that the use of ELS in dairy cow diets could improve energy density as well as milk fatty acid profiles, while limiting the harmful effects of PUFAs on the rumen environment and its functions. Thus, we quantified the impact of feeding ELS on dairy cow milk yield and composition (including fatty acid profiles), feed efficiency, first-service conception rate, and mastitis incidence.
2. Materials and Methods
2.1. Animals and Experimental Design
This study was conducted on a private dairy farm located in Damietta province, Egypt. The dairy herd consisted of 1238 Holstein cows with an average milk yield of less than 8000 L per season, a parity number of 2.18 (range 1–9 parity), and a peak milk yield of 38 L. Seventy-eight nonpregnant multiparous Holstein dairy cows were selected from the dairy herd according to their average daily milk yield in the previous 15 days (pretreatment), days in milk (DIM), parity, and reproductive potential. All animal protocols followed the experimentation guidelines of the Internal Commission for Environmental and Ethics of Alexandria University (approval number: ALEXU-0089-2019).
The selected dairy cows were randomly divided into two groups, 39 animals in each. The first served as a control, while the second was assigned as the supplemented group. The control group was fed a lactation ration according to the NRC recommendations [
27] for 38 days (
Table 1). The second group was fed the same lactation diet supplemented with a Mix-Promega3 dietary supplement (Kemit Co., Cairo, Egypt) at 100 g/kg of dry matter (DM) for 38 consecutive days (
Table 1). Mix-Promega3 is a dietary supplement that contains 650 g/kg extruded linseed, 150 g/kg extruded soybean, and 200 g/kg rice bran (details given in
Table 2 and
Table 3). This supplement is produced by Kemit Co. for Advanced Nutrition (patent no. 3904 at 204,8128). The supplement is composed of seeds which are ground, then mixed and extruded (with extruders using water steam at temperatures greater than 100 °C for 10–30 min). Nutritive values of the tested rations were calculated, including net energy (NE) (i.e., Unité Fourragère Lait (UFL): one UFL = 1700 Kcal of NE) and protein (digested in the small intestine when nitrogen (PDIN) or energy (PDIE) were calculated according to INRA (2010)). The requirements of UFL and PDI for maintenance and milk production were calculated from the body weight (BW), milk yield, and milk protein percentage. The UFL and PDI supplies were calculated using the total mixed ration (TMR) intake and its respective concentrations in UFL and PDI (INRA, 2010). Energy and protein balance were calculated by subtracting energy or protein requirement from their intake.
Before the study began, the average daily milk yields per cow were 30.6 ± 0.1 and 30.4 ± 0.1 kg for the control and the treated groups, respectively. The average DIM was 80.3 ± 6 and 82.4 ± 5 d and the parities were 3.2 ± 0.01 and 3.1 ± 0.01 for the control and the treated groups, respectively. All test subjects from both groups were acclimatized by feeding with the control diet for 15 days before the beginning of experimental treatments. Each group was placed in separate free-stall barns with a 20% roofed area, open sides, and sandy floors. All test subjects were milked three times daily in a herringbone milking parlor equipped with automatic take-off systems and automated recording systems (ALPRO). Milking and machine management practices were conducted according to the standard management system used for Holstein dairy herds.
2.2. Ration Analysis
The TMR was offered to each cow group four times per day, and the remaining uneaten rations were weighed at 7 AM the following day. Samples were taken from each ration biweekly and dried for 48 h at 60 °C. By the end of the study, aliquots were taken from each sample for further proximate analyses. Samples were ground and their chemical compositions analyzed according to procedures described by the AOAC [
28]. Crude protein (N × 6.25) content was analyzed using the Kjeldahl method (procedure 928.08). Crude fat (procedure 948.15) content was estimated using petroleum ether in a Soxtec System. Acid detergent fiber (ADF) and neutral detergent fiber (NDF) were estimated according to the procedure of Van Soest et al. [
29], adapted for the Fiber Analyzer. All chemical analyses were completed using dry matter (DM).
2.3. Lactation Performance Data
One dairy cow was removed from the supplemented group during the study due to illness (a severe form of lameness). DIM and parity data were obtained from an on-farm recording system (dairy-Comb). Daily milk yield for each cow was obtained directly from the milking parlor recording system (ALPRO) once per week.
2.4. Milk Composition and Fatty Acids Profile
All cows were milked three times per day with eight-hour intervals. Samples of milk were collected biweekly from three consecutive milking events and then pooled for each cow. Bronopol tablets (D&F Control System, San Ramon, CA, USA) were added to each sample as a preservative and then the samples were stored at 4 °C. The samples were analyzed for solid not fat (SNF), protein concentrations, and fat concentrations using the Milko-Scan S50 analyzer (Foss Tecator, Hillerød, Denmark).
Fatty acid composition, in terms of unsaturated fatty acids (USFAs), saturated fatty acids (SFAs), polyunsaturated fatty acids (PUFAs), monounsaturated fatty acids (MUFAs), α-linolenic acid, and conjugated linoleic acid were analyzed using capillary gas chromatography according to the method described in the guidelines of AOAC [
28] (procedure 996.01). The analysis was performed in the Faculty of Agriculture, Cairo University, Giza, Egypt. Milk samples were centrifuged (2000×
g) to extract the fat cake. Lipid extraction was then completed following the method of Hara and Radin [
30] by adding 18 mL of isopropanol plus hexane (2:3,
v/
v) to each gram of fat cake. The solution was mixed and then 12 mL of 6.7% NaSO
4 was added. The hexane layer was transferred to a tube containing one gram of NaSO
4. Once 30 min had elapsed, the hexane layer was extracted and stored at −20 °C until further analysis (methylation).
Fatty acid methylation was conducted according to a method outlined by Ostrowska et al. [
31]. Thirty milligrams of the extracted fat from each sample was inserted into 15 mL test tubes fitted with Teflon-lined screw caps. Then, 1.5 mL of 0.5 N NaOH dissolved in methyl alcohol was added. The tubes were flushed with nitrogen, closed, and heated at 100 °C. They were then shaken for 5 min and cooled to room temperature. One milliliter of an internal standard (2 mg heptadecanoic acid, C17:0/mL in hexane) plus 2 mL of boron trifluoride (14%) in methanol were added and the solutions were heated with occasional shaking at 100 °C for 5 min. Ten milliliters of deionized water was then added to each solution. Each solution was transferred to 40 mL centrifuge tubes and 5 mL of hexane was added (to extract fatty acid methyl esters). Afterwards, the solutions were centrifuged (2000×
g) at 10 °C for 20 min. The hexane layers were dried using sodium sulfate, collected in vials and analyzed using gas chromatography (Hewlett Packard GC system HP6890 A, Hewlett Packard, Avondale, PA, USA). The chromatography machine contained a 100 m × 0.25 mm fused silica capillary column (SP2560, Supelco Inc, Bellefonte, PA, USA). The injector and detector temperatures were 240 °C. During each analysis run, the column temperature was maintained at 70 °C for the first 4 min. It then increased by 13 °C per minute until it reached 175 °C. It was maintained at 175 °C for the next 27 min. The temperature then increased by 4 °C per minute until it reached 215 °C. It was maintained at this temperature for the last 31 min of the run. Pure methyl ester standards (GLC-569, NuChek Prep, Elysian, MN, USA) were used to identify and quantify fatty acid peaks. In order to correct the loss of short-chain fatty acids during the preparation of the sample, butter oil reference standards (CRM 164; Commission of European Communities, Community Bureau of Reference, Brussels, Belgium) were used as an external standard.
2.5. First-Service Conception Rate
Artificial insemination of each dairy cow was completed by the herd veterinarian following the appearance of true physical estrus signs. Pregnancies were diagnosed using ultrasonography 28–36 days following the last insemination. The first insemination conception rate was calculated for control and treated groups according to the following formula:
2.6. Clinical Mastitis
Clinical mastitis cases were suspected when abnormal milk was found during foremilk stripping by milking personnel and confirmed by a veterinarian. The California Mastitis Test was used to confirm diagnoses (where any degrees of reaction were considered positive). Dairy cows with clinical mastitis were treated after each milking session with an intramammary injection containing an approved antibiotic formula (flumethasone, neomycin, and spiramycin) for three days.
2.7. Statistical Analysis
The parametric data were analyzed with repeated measures using the PROC MIXED method in the SAS software [
32]. All continuous parameters (daily milk yield, milk solids) were covariables and were calculated from 15 days before the treatments began. Milk yields and milk fatty acid profiles were analyzed using General linear models (GLMs), and the results were represented as least square means and SEM. The GLM model structures were as follows:
where μ = overall mean, T
i = treatment effect, i = 1 or 2, P
j = parity, j = 2 or greater, C (T × P)
ijk = cow k nested in treatment i and in parity j; DIM
ijkl = days in milk; and E
ijklm = a random residual.
Once the main treatment effect was found to be significant, a pairwise t-test (the ‘pdiff’ option of PROC MIXED, SAS software) was performed to separate means. The clinical mastitis incidences in different groups were analyzed using the chi-square test. Explanatory variables with two levels, e.g., first-service conception rate (pregnancy and nonpregnancy) and mastitis incidence (infected and noninfected), were analyzed using a categorical method (chi-square analyses).
4. Discussion
Milk quality is one of the most important critical issues affecting the dairy industry. The present study aimed to improve milk quality and dairy cows’ productive and reproductive performances by supplementing their diets with ELS. Cows that were fed this supplemented diet for 38 consecutive days were found to increase their milk production by 3.26% relative to the control group. This result is consistent with previous studies [
11,
17] but contrasts with several others [
15,
16,
33,
34] that researched the use of extruded linseed (EL) in cow diets. Our finding in relation to the increased milk yields in the ELS group may be attributed to the presence of extruded soybean in our supplemented diet (regardless of the small proportion included in the mixture). Giallongo et al. [
18] suggested that increases in milk yield due to dietary extruded soybean supplementation may be related to an increase in dry matter, crude protein, and fiber intake. In the current investigation, PDIE intake as well as energy and protein balance were increased in the ELS group, which likely clarifies the variances in milk production between the experimental diets.
In the present study, supplementation with ELS decreased the percentage of milk fat. This is consistent with some previous studies that found that diets supplemented with extruded linseed resulted in a decrease in the percentage of milk fat [
17,
35]. However, this decrease was not recorded in other studies that supplemented cow diets with whole [
33,
36] or extruded linseed [
17,
37]. We found that supplementing cow diets with ELS did not affect milk protein concentrations or yields. This result is consistent with previous studies [
33,
36,
37].
Our observation that milk fat content of C16 and C18 decreased with ELS feeding is contradictory with the results of other studies [
38,
39]. This response might be related to higher milk fat contents of C18:2 trans-10, cis-12 [
40]. Several studies have found that feeding diets containing EL caused a reduction in SFA concentrations and an increase in MUFA concentrations [
15,
17,
35,
37], similar to the findings in the present study. We found that the concentrations of PUFAs, ALA, and CLA in dairy cows’ milk increased following diet supplementation with ELS. These results are consistent with previous studies [
11,
15,
37]. Neveu et al. [
15] found that EL supplementation improves milk fat USFAs, α-linolenic acid, and conjugated linoleic acid in the milk of dairy cows.
In this study, DM intake did not differ between the ELS and the control groups, and this is consistent with previous studies [
41,
42,
43]. Previous studies also reported no change in the intakes of DM and NEL when the concentration of total fat was less than 6% of DM. In contrast, Martin et al. [
44] found that supplementation with linseed oil at a rate of 5.7% DM caused a significant decrease in dry matter intake (DMI). However, they also found that supplementation of the dairy ration with either crude or extruded linseed did not affect DMI. Similar outcomes were reported by Lerch et al. [
33].
Once dairy cows have calved, successful conception following the first service is essential in order to maximize reproductive efficiency [
45]. Lower conception rates after the first service may result in an increase in repeated insemination procedures, days open, reproductive medication, culling, and replacement heifers [
46]. In this study, the first service conception rate ranged from 40.91% in Holstein dairy cows fed the control diet, and 44.44% in cows fed the ELS diet. This range is within the range of 26.7% to 50.7% reported by previous studies [
47,
48]. Our finding that the first-service conception rate of dairy cows did not alter depending on the experimental diets is consistent with previous studies that reported conception and pregnancy rates to be unchanged when diets were supplemented with linseed, saturated FA, or n-6 FA [
41,
49]. Similarly, in another study, there was no significant difference in conception rates at first service when lactating cows were fed a diet supplemented with rolled flaxseed versus a control [
50]. In contrast, some studies have found that feeding extruded linseed to dairy cows was associated with a reduced number of days required before first artificial insemination as well as reduced days to conception, but they did not relate diet to the overall rate of return to service [
51,
52]. The lack of effects of ELS on first-service conception rates in the present study may be attributable to the observed improvements in milk production in ELS-supplemented cows, which resulted in a negative energy balance. In addition, if, as in our study, a low number of cows were subjected to a first service, this may have contributed to the fact that there was no difference in the conception rate between the ELS-supplemented cows (44.4%) and those in the control (40.91%) [
53].
Several studies on dairy cows have confirmed that PUFAs from plant sources have beneficial effects as modulators of the inflammatory and immune responses [
21,
22,
23]. A negative correlation has been found between mastitis incidence and immune traits [
24]. It is thought that n-3 fatty acids may influence cell immunity in the mammary gland. In this context, the lymphocyte proliferative reaction was found to decrease in dairy cows subjected to a linseed treatment five days after calving [
23]. Mach et al. [
54] observed that mammary gland immune function in midlactation cows was positively affected by diet supplementation with unsaturated fatty acids. In this way, mastitis susceptibility may be reduced. Surprisingly, in our study, mastitis incidence in dairy cows was not significantly different between the experimental groups. To our knowledge, there are few studies to date on the effects of extruded oilseed supplementation on the incidence of mastitis in dairy cows. The reasons underlying the absence of a significant ELS effect on mastitis incidence in the current study are unknown. However, as for during the lactation stage, the reasons may be related to the concentration used or the low number of lactating cows included in our study. Thus, we recommended that future studies on this issue incorporate a larger number of lactating cows in different stages of lactation and various ELS concentrations into their experimental designs.